健康和安全介紹 Health and Safety Induction 非洲礦業(yè)有限公司AML HSE安全管理制度 英文版

1、HEALTH AND SAFETY INDUCTION,Revised by African Minerals Health Services April 2011,Lungi,Freetown,African Minerals Project Area a job method is changed; a job process is changed; or a safety inspection shows that the job is not being performed according to the JSA,Job Safety Analysis (JSA),Personal

2、Protective Equipment (PPE) is not a substitute for safe working practices, it is an additional protective barrier to prevent injury Minimum PPE requirements are: Safety Helmet check for dents, cracks and expiry date. Do not drill holes, store in extreme temperatures, clean with heavy solvents or pla

3、ce stickers on your safety helmet Safety boots leather lace up, steel capped with slip resistant, chemical resistant and puncture resistant soles Approved safety glasses Long sleeved shirt and long trousers Safety Vests Insect repellent for night workers,Personal Protective Equipment,Wearing of PPE

4、in designated areas is mandatory Additional PPE and clothing requirements shall be identified via a JSA prior to commencing work. Replace any damaged and poorly fitting PPE,Personal Protective Equipment,When it is not feasible to reduce the noise or its duration use ear protective devices Hearing pr

5、otection recommended above 85 db(A),Ear Protection,NO HEIGHT IS A SAFE HEIGHT Any open edge higher than 2 meters requires Guardrail System Safety Net System Personal Fall Arrest System (Body Harness) Any fixed ladder higher than 2 meters requires No less than two workers per ladder Ladder Safety Dev

6、ice (with body harness) Any height where a person can free fall greater than 600mm will require some form of fall protection,Fall Protection,Standard safety signs are classified as: Prohibition sign = red and white Mandatory sign = blue Warning sign = yellow and black Emergency related sign = red Sa

7、fety related sign = red and green Signs shall be visible at all times Prohibition, danger caution and warning signs must be visible on approach to a hazard, at a reasonable distance from the hazard to allow time to read and heed the warning,Safety Signs,Mandatory signs,Prohibition Signs,Safety Signs

8、,Temporary Barriers: Barriers shall be erected with appropriate signage to indicate to site personnel the restriction and or actions required. An information tag must be attached to the temporary barrier Only those personnel assigned to the work are permitted in a barricaded area All signage and bar

9、riers must be removed on completion of work to remove confusion,Temporary Barriers,Always use barricading when erecting scaffolding Always inspect scaffolding before use Never use incomplete or uncertified scaffold. Never make unauthorised alterations. Never climb up on the guard/handrails to gain e

10、xtra height. Never drop or throw things down from scaffolding. Use correct PPE (full body harness) when working at a height of 2 meters or above if guard/handrails are absent. Must always be erected by a qualified scaffold erecter,Access Scaffolding,Keep all walkways and stairways clear Store all ma

11、terials in their designated areas Put tools and equipment away after use Use rubbish bins where provided Where practicable clean up spills as soon as they happen A job is not complete until the place of work is tidy,Housekeeping,Water/Air Safety,Always wear life vests on water craft Life vests shoul

12、d be donned prior to leaving hard standing Life vests should not be removed until arriving on hard standing Pay attention to the possibilities for trips, slips or falls on the jetties/pontoons Careful climbing into If there is no response DO NOT pass,RIGHT MIRROR,LEFT MIRROR,NO VISIBILITY,VISIBLE AR

13、EA,NO VISIBILTY,NO VISIBILTY,18 METERS,NO VISIBILTY,7 METERS,Caterpillar 777 “Blind Spots”,Transport Safety,Ensure that Journey Management are aware of your intended route, expected time of arrival, number of people travelling, registration of the vehicle Make sure Journey Management is notified onc

14、e destination is reached Ensure the driver has replenished the vehicle with fuel for the whole journey Make sure there is a supply of drinking water on board Inform Journey Management if there is any delay (puncture, road block, weather etc.) or change in original journey plan (e.g. route change) Co

15、ntact Journey Management on freetownopssecurityafrican- or phone 033 633 832,Journey Management,Permit Types,Hot work = welding, grinding, cutting Work at height = erecting scaffolding, roof work Confined space entry = tanks, vessels, pits Electrical isolation = motors, switch boards Excavation = tr

16、enching Radiation = plant x-ray equipment,Permit to Work System,Upon discovery of a fire,Raise the alarm or shout “FIRE, FIRE, FIRE” Get everybody out DIAL EMERGENCY SITE/AML OPS NUMBER If safe to do so, try and extinguish the fire using the correct type of fire extinguisher If not, leave the area o

17、r building closing any doors behind you Proceed to nearest assembly/muster point,In Case of Fire,Medical Incidents,All accidents, which involve personal injury, no matter how minor, must be reported to your Supervisor Make sure that you know the location of the site medical centre, the nearest first

18、 aid box and the number of the nearest Paramedic (for general/minor heath issues) All medical emergencies must go through the site/AML Ops centre,Health,Temperature Stress - Heat,To avoid heat stress keep yourself well hydrated drink 2-3 litres of water per day (drink small amounts often) Wear head

19、and body PPE for protection from sun lightweight long sleeves, hat, sunblock Wear dark safety glasses when working outside in the sun. Ensure you change your dark glasses to clear ones when returning inside, working in shaded areas or buildings Arrange heavy work task for the beginning of a shift (t

20、he team is fresh, coolest part of the day) Any signs of heat stress report it immediately to your supervisor; these include heavy sweating, muscle cramps, dizziness, headache, nausea/vomiting or fainting,Health,All accidents/incidents/near misses must be reported immediately to your supervisor Your

21、supervisor will escalate as required under African Minerals accident reporting procedure Initial investigation must be completed within 24 hours A full investigation may take longer, however, an initial investigation will be required so that any remedial corrective actions can be taken Please forwar

22、d all incidents reports and associated correspondence to AMLIncidentReportafrican-,Incident reporting,Inspect your work area before commencing work. Be an observer STAY ALERT Housekeeping! Housekeeping! Housekeeping! Use your best safety device THINK If youre not sure ASK (no question is a stupid question) Report all injuries/incidents/hazards/illnesses Report all safety issues to the Safety Supervisor or your team supervisor,Good safety practice