液冷系統服務器的最高運行溫度測試與優化2015.01.14

1、實實驗驗名名稱稱液冷系統服務器的最高運行溫度測試與優化測測試試對對象象服務器最高運行溫度實實驗驗?zāi)磕康牡臏y(cè)定液冷系統中服務器的最高運行溫度，實驗提高運行溫度的方法實實驗驗環環境境2U實驗平臺測測試試人人員員林智 廖雄龍 劉自利 譚水兵實實驗驗設設備備DELL C6100（XEON L5650*2/48G/160G-SSD）*4 泰仕測溫儀 溫度探頭 常規銅散熱片 改良銅散熱片 三合一鋁散熱片 銦片實實驗驗方方法法/ /步步驟驟按照測試要求安裝服務器，并放入2U實驗平臺，注入PAO4導熱油。開啟油泵及鼓風機，將油流量調至所需的流量。調節鼓風機頻率使油溫以合適的速度上升，從回油溫度達到45左右開始

2、記錄數據（包括時間、進油溫度、出油溫度、各散熱片溫度、各CPU溫度），直到服務器死機。測試組1，測試條件：常規銅散熱片，不加銦片，流量0.4m3/h。測試組2，測試條件：改良銅散熱片，不加銦片，流量0.4m3/h。測試組3，測試條件：三合一鋁散熱片，不加銦片，流量0.4m3/h。測試組4，測試條件：改良銅散熱片，加銦片，流量0.4m3/h。測試組5，測試條件：改良銅散熱片，加銦片，流量0.4m3/h，雙電源外置。測試組6，測試條件：改良銅散熱片，加銦片，流量0.4m3/h，單電源外置并修改供電電路。更換硅油進行測試測試組7，測試條件：改良銅散熱片，加銦片，流量0.4m3/h，單電源外置并修改供

3、電電路。測試組8，測試條件：改良銅散熱片，加銦片，流量0.4m3/h，用IBMI命令修改環境溫度為52、55、60分別進行測試。測試組9，測試條件：原廠散熱片，流量0.4m3/h，分別測試HP SE316M1和DELL C6220兩種服務器的最高運行溫度及其影響因素。實實驗驗結結論論通過改良散熱片和添加銦片可優化CPU的散熱，可使CPU節點溫度與導熱油之間的溫差縮小約7。通過改良散熱片可改善高粘度導熱油對翅片散熱的不利影響。影響DELL C6100服務器死機溫度的主要因素為主板上的環境溫度故障閾值與電源供電無關，當油柜出油溫度到達故障閾值時，服務器便會自動切斷電源供電?？赏ㄟ^改造供電電路及更換

4、電源控制電路板來屏蔽故障信號，或采用IBMI命令修改環境溫度故障閾值（關機后會重置）來提高C6100的最高運行溫度。通過第點的修改，經測試DELLC6100最高運行溫度達61（出油溫度），此時CPU最高溫度為88，之后由于CPU溫度達到故障閾值導致服務器死機。 DELL C6220經測試無環境溫度故障閾值限制，當CPU溫度到達故障閾值時，系統會自動降頻不會出現死機。HP SE316M1服務器環境溫度故障閾值為47，但環境溫度高于47時只會報警不會出現死機，測試時環境溫度最高到達50。匯匯簽簽設計校核審批DELLDELL C6100C6100服服務務器器的的最最高高運運行行溫溫度度測測試試與與優

5、優化化序號時間測試條件測試數據散熱片環境溫度閾值導熱界面材料導熱介質油流量電源配置CPU0溫度（A）CPU1溫度（A）12015/12/15 14:57改良銅散熱片50無PAO40.45雙電源內置746722015/12/15 14:59改良銅散熱片50無PAO40.45雙電源內置756832015/12/15 15:02改良銅散熱片50無PAO40.45雙電源內置746842015/12/15 15:04改良銅散熱片50無PAO40.45雙電源內置756952015/12/15 15:07改良銅散熱片50無PAO40.45雙電源內置766962015/12/15 15:11改良銅散熱片50無

6、PAO40.45雙電源內置766972015/12/15 15:13改良銅散熱片50無PAO40.45雙電源內置776982015/12/15 15:16改良銅散熱片50無PAO40.45雙電源內置787192015/12/15 15:19改良銅散熱片50無PAO40.45雙電源內置7770102015/12/15 15:24改良銅散熱片50無PAO40.45雙電源內置7872112015/12/15 15:26改良銅散熱片50無PAO40.45雙電源內置7873122015/12/15 15:30改良銅散熱片50無PAO40.45雙電源內置7972132015/12/15 15:35改良銅散

7、熱片50無PAO40.45雙電源內置8074142015/12/15 15:40改良銅散熱片50無PAO40.45雙電源內置7977152015/12/15 15:44改良銅散熱片50無PAO40.45雙電源內置8176162015/12/15 15:47改良銅散熱片50無PAO40.45雙電源內置8277172015/12/15 15:51改良銅散熱片50無PAO40.45雙電源內置8378182015/12/15 15:55改良銅散熱片50無PAO40.45雙電源內置8378192015/12/16 10:49常規銅散熱片50無PAO40.45雙電源內置8175202015/12/16 1

8、0:52常規銅散熱片50無PAO40.45雙電源內置8175212015/12/16 10:57常規銅散熱片50無PAO40.45雙電源內置8176222015/12/16 11:00常規銅散熱片50無PAO40.45雙電源內置8175232015/12/16 11:02常規銅散熱片50無PAO40.45雙電源內置8277242015/12/16 11:05常規銅散熱片50無PAO40.45雙電源內置8277252015/12/16 11:10常規銅散熱片50無PAO40.45雙電源內置8278262015/12/16 11:13常規銅散熱片50無PAO40.45雙電源內置8478272015

9、/12/16 11:16常規銅散熱片50無PAO40.45雙電源內置8578282015/12/16 11:18常規銅散熱片50無PAO40.45雙電源內置8678292015/12/16 11:21常規銅散熱片50無PAO40.45雙電源內置死機死機302015/12/16 15:00三合一鋁散熱片50無PAO40.45雙電源內置7777312015/12/16 15:03三合一鋁散熱片50無PAO40.45雙電源內置7878322015/12/16 15:04三合一鋁散熱片50無PAO40.45雙電源內置7878332015/12/16 15:06三合一鋁散熱片50無PAO40.45雙電源

10、內置7979342015/12/16 15:07三合一鋁散熱片50無PAO40.45雙電源內置8179352015/12/16 15:08三合一鋁散熱片50無PAO40.45雙電源內置7978362015/12/16 15:09三合一鋁散熱片50無PAO40.45雙電源內置8078372015/12/16 15:11三合一鋁散熱片50無PAO40.45雙電源內置8273382015/12/16 15:12三合一鋁散熱片50無PAO40.45雙電源內置8178392015/12/16 15:13三合一鋁散熱片50無PAO40.45雙電源內置8179402015/12/16 15:14三合一鋁散熱

11、片50無PAO40.45雙電源內置8179412015/12/16 15:15三合一鋁散熱片50無PAO40.45雙電源內置8179422015/12/16 15:16三合一鋁散熱片50無PAO40.45雙電源內置8179432015/12/16 15:17三合一鋁散熱片50無PAO40.45雙電源內置8380442015/12/16 15:18三合一鋁散熱片50無PAO40.45雙電源內置8380452015/12/16 15:19三合一鋁散熱片50無PAO40.45雙電源內置死機死機462015/12/16 17:00改良銅散熱片50銦片PAO40.45雙電源內置7275472015/12

12、/16 17:04改良銅散熱片50銦片PAO40.45雙電源內置7176482015/12/16 17:10改良銅散熱片50銦片PAO40.45雙電源內置7177492015/12/16 17:14改良銅散熱片50銦片PAO40.45雙電源內置7276502015/12/16 17:19改良銅散熱片50銦片PAO40.45雙電源內置7477512015/12/16 17:24改良銅散熱片50銦片PAO40.45雙電源內置7476522015/12/16 17:29改良銅散熱片50銦片PAO40.45雙電源內置7577532015/12/16 17:33改良銅散熱片50銦片PAO40.45雙電源

13、內置7678542015/12/16 17:35改良銅散熱片50銦片PAO40.45雙電源內置7778552015/12/16 17:39改良銅散熱片50銦片PAO40.45雙電源內置死機死機562015/12/17 10:26改良銅散熱片50銦片PAO40.45雙電源內置7472572015/12/17 10:30改良銅散熱片50銦片PAO40.45雙電源內置7476582015/12/17 10:34改良銅散熱片50銦片PAO40.45雙電源內置7675592015/12/17 10:36改良銅散熱片50銦片PAO40.45雙電源內置7676602015/12/17 10:40改良銅散熱片

14、50銦片PAO40.45雙電源內置7577612015/12/17 10:44改良銅散熱片50銦片PAO40.45雙電源內置7578622015/12/17 10:50改良銅散熱片50銦片PAO40.45雙電源內置7578632015/12/17 10:52改良銅散熱片50銦片PAO40.45雙電源內置7478642015/12/17 10:58改良銅散熱片50銦片PAO40.45雙電源內置7478652015/12/17 11:01改良銅散熱片50銦片PAO40.45雙電源內置死機死機662015/12/18 11:22改良銅散熱片50銦片PAO40.45雙電源內置7173672015/12

15、/18 11:27改良銅散熱片50銦片PAO40.45雙電源內置7073682015/12/18 11:30改良銅散熱片50銦片PAO40.45雙電源內置7272692015/12/18 11:33改良銅散熱片50銦片PAO40.45雙電源內置7073702015/12/18 11:42改良銅散熱片50銦片PAO40.45雙電源內置6971712015/12/18 11:44改良銅散熱片50銦片PAO40.45雙電源內置6671722015/12/18 11:46改良銅散熱片50銦片PAO40.45雙電源內置6771732015/12/18 11:50改良銅散熱片50銦片PAO40.45雙電源

16、內置6671742015/12/18 11:52改良銅散熱片50銦片PAO40.45雙電源內置6870752015/12/18 11:56改良銅散熱片50銦片PAO40.45雙電源內置6770762015/12/18 12:00改良銅散熱片50銦片PAO40.45雙電源內置6769772015/12/18 12:04改良銅散熱片50銦片PAO40.45雙電源內置6770782015/12/18 12:06改良銅散熱片50銦片PAO40.45雙電源內置6769792015/12/18 12:10改良銅散熱片50銦片PAO40.45雙電源內置6770802015/12/18 12:12改良銅散熱片

17、50銦片PAO40.45雙電源內置7275812015/12/18 12:16改良銅散熱片50銦片PAO40.45雙電源內置7376822015/12/18 12:18改良銅散熱片50銦片PAO40.45雙電源內置7376832015/12/18 12:21改良銅散熱片50銦片PAO40.45雙電源內置7376842015/12/18 12:23改良銅散熱片50銦片PAO40.45雙電源內置7376852015/12/18 12:26改良銅散熱片50銦片PAO40.45雙電源內置7376862015/12/18 12:28改良銅散熱片50銦片PAO40.45雙電源內置7376872015/12

18、/18 12:30改良銅散熱片50銦片PAO40.45雙電源內置7377882015/12/18 12:35改良銅散熱片50銦片PAO40.45雙電源內置7476892015/12/18 12:37改良銅散熱片50銦片PAO40.45雙電源內置7477902015/12/18 12:40改良銅散熱片50銦片PAO40.45雙電源內置7477912015/12/18 12:43改良銅散熱片50銦片PAO40.45雙電源內置7476922015/12/18 12:46改良銅散熱片50銦片PAO40.45雙電源內置7578932015/12/18 12:49改良銅散熱片50銦片PAO40.45雙電源

19、內置7578942015/12/18 12:52改良銅散熱片50銦片PAO40.45雙電源內置7477952015/12/18 12:56改良銅散熱片50銦片PAO40.45雙電源內置7478962015/12/18 12:59改良銅散熱片50銦片PAO40.45雙電源內置死機死機972015/12/21 14:53改良銅散熱片50銦片PAO40.40單電源外置7172982015/12/21 14:55改良銅散熱片50銦片PAO40.40單電源外置7173992015/12/21 14:57改良銅散熱片50銦片PAO40.40單電源外置72751002015/12/21 14:59改良銅散熱

20、片50銦片PAO40.40單電源外置72751012015/12/21 15:02改良銅散熱片50銦片PAO40.40單電源外置72751022015/12/21 15:05改良銅散熱片50銦片PAO40.40單電源外置73761032015/12/21 15:08改良銅散熱片50銦片PAO40.40單電源外置72761042015/12/21 15:10改良銅散熱片50銦片PAO40.40單電源外置72771052015/12/21 15:13改良銅散熱片50銦片PAO40.40單電源外置73761062015/12/21 15:16改良銅散熱片50銦片PAO40.40單電源外置737610

21、72015/12/21 15:19改良銅散熱片50銦片PAO40.40單電源外置74741082015/12/21 15:22改良銅散熱片50銦片PAO40.40單電源外置74751092015/12/21 15:25改良銅散熱片50銦片PAO40.40單電源外置75751102015/12/21 15:28改良銅散熱片50銦片PAO40.40單電源外置76751112015/12/21 15:32改良銅散熱片50銦片PAO40.40單電源外置76771122015/12/21 15:35改良銅散熱片50銦片PAO40.40單電源外置76771132015/12/21 15:38改良銅散熱片5

22、0銦片PAO40.40單電源外置77771142015/12/21 15:41改良銅散熱片50銦片PAO40.40單電源外置77781152015/12/21 15:44改良銅散熱片50銦片PAO40.40單電源外置77781162015/12/21 15:47改良銅散熱片50銦片PAO40.40單電源外置77781172015/12/21 15:50改良銅散熱片50銦片PAO40.40單電源外置78781182015/12/21 15:53改良銅散熱片50銦片PAO40.40單電源外置77791192015/12/21 15:56改良銅散熱片50銦片PAO40.40單電源外置78791202

23、015/12/21 15:59改良銅散熱片50銦片PAO40.40單電源外置77801212015/12/21 16:02改良銅散熱片50銦片PAO40.40單電源外置77771222015/12/21 16:05改良銅散熱片50銦片PAO40.40單電源外置78891232015/12/21 16:08改良銅散熱片50銦片PAO40.40單電源外置80791242015/12/21 16:11改良銅散熱片50銦片PAO40.40單電源外置79791252015/12/21 16:14改良銅散熱片50銦片PAO40.40單電源外置78801262015/12/21 16:18改良銅散熱片50銦

24、片PAO40.40單電源外置79801272015/12/21 16:21改良銅散熱片50銦片PAO40.40單電源外置78821282015/12/21 16:25改良銅散熱片50銦片PAO40.40單電源外置80801292015/12/21 16:29改良銅散熱片50銦片PAO40.40單電源外置80801302015/12/21 16:32改良銅散熱片50銦片PAO40.40單電源外置81811312015/12/21 16:36改良銅散熱片50銦片PAO40.40單電源外置81821322015/12/21 16:40改良銅散熱片50銦片PAO40.40單電源外置8181133201

25、5/12/21 16:44改良銅散熱片50銦片PAO40.40單電源外置80811342015/12/21 16:48改良銅散熱片50銦片PAO40.40單電源外置80821352015/12/21 16:53改良銅散熱片50銦片PAO40.40單電源外置80811362015/12/21 16:58改良銅散熱片50銦片PAO40.40單電源外置80821372015/12/21 17:04改良銅散熱片50銦片PAO40.40單電源外置81851382015/12/21 17:09改良銅散熱片50銦片PAO40.40單電源外置80831392015/12/21 17:14改良銅散熱片50銦片P

26、AO40.40單電源外置81851402015/12/21 17:19改良銅散熱片50銦片PAO40.40單電源外置80841412015/12/21 17:26改良銅散熱片50銦片PAO40.40單電源外置80851422015/12/21 17:31改良銅散熱片50銦片PAO40.40單電源外置80861432015/12/21 17:36改良銅散熱片50銦片PAO40.40單電源外置80861442015/12/21 17:42改良銅散熱片50銦片PAO40.40單電源外置82851452015/12/21 17:46改良銅散熱片50銦片PAO40.40單電源外置84861462015/

27、12/21 17:49改良銅散熱片50銦片PAO40.40單電源外置84861472015/12/21 17:51改良銅散熱片50銦片PAO40.40單電源外置84861482015/12/21 17:53改良銅散熱片50銦片PAO40.40單電源外置84861492015/12/21 17:59改良銅散熱片50銦片PAO40.40單電源外置85851502015/12/21 18:03改良銅散熱片50銦片PAO40.40單電源外置86851512015/12/21 18:06改良銅散熱片50銦片PAO40.40單電源外置86851522015/12/21 18:10改良銅散熱片50銦片PAO

28、40.40單電源外置86851532015/12/21 18:13改良銅散熱片50銦片PAO40.40單電源外置86851542015/12/21 18:16改良銅散熱片50銦片PAO40.40單電源外置86851552015/12/24 10:21改良銅散熱片50銦片PAO40.45雙電源外置68731562015/12/24 10:27改良銅散熱片50銦片PAO40.45雙電源外置70731572015/12/24 10:32改良銅散熱片50銦片PAO40.45雙電源外置72741582015/12/24 10:37改良銅散熱片50銦片PAO40.45雙電源外置75771592015/12

29、/24 10:42改良銅散熱片50銦片PAO40.45雙電源外置74781602015/12/24 10:48改良銅散熱片50銦片PAO40.45雙電源外置77781612015/12/31 14:47改良銅散熱片50銦片硅油0.40單電源外置70721622015/12/31 14:54改良銅散熱片50銦片硅油0.40單電源外置71721632015/12/31 15:03改良銅散熱片50銦片硅油0.40單電源外置73741642015/12/31 15:11改良銅散熱片50銦片硅油0.40單電源外置74751652015/12/31 15:17改良銅散熱片50銦片硅油0.40單電源外置75

30、761662015/12/31 15:23改良銅散熱片50銦片硅油0.40單電源外置77771672015/12/31 15:33改良銅散熱片50銦片硅油0.40單電源外置78781682015/12/31 15:41改良銅散熱片50銦片硅油0.40單電源外置79781692015/12/31 15:50改良銅散熱片50銦片硅油0.40單電源外置81801702015/12/31 15:59改良銅散熱片50銦片硅油0.40單電源外置83831712015/12/31 16:11改良銅散熱片50銦片硅油0.40單電源外置84841722015/12/31 16:20改良銅散熱片50銦片硅油0.4

31、0單電源外置84841732015/12/31 16:29改良銅散熱片50銦片硅油0.40單電源外置84841742015/12/31 16:37改良銅散熱片50銦片硅油0.40單電源外置85851752015/12/31 16:45改良銅散熱片50銦片硅油0.40單電源外置85871762015/12/31 16:53改良銅散熱片50銦片硅油0.40單電源外置88871772015/12/31 17:00改良銅散熱片50銦片硅油0.40單電源外置88871782015/12/31 17:11改良銅散熱片50銦片硅油0.40單電源外置88881792015/12/31 17:25改良銅散熱片5

32、0銦片硅油0.40單電源外置88881802015/1/6 14:33改良銅散熱片55銦片硅油0.45雙電源內置74701812015/1/6 14:37改良銅散熱片55銦片硅油0.45雙電源內置74701822015/1/6 14:41改良銅散熱片55銦片硅油0.45雙電源內置75721832015/1/6 14:45改良銅散熱片55銦片硅油0.45雙電源內置77721842015/1/6 14:48改良銅散熱片55銦片硅油0.45雙電源內置78741852015/1/6 14:50改良銅散熱片55銦片硅油0.45雙電源內置81751862015/1/6 14:52改良銅散熱片55銦片硅油0

33、.45雙電源內置80771872015/1/6 14:54改良銅散熱片55銦片硅油0.45雙電源內置80751882015/1/6 14:56改良銅散熱片55銦片硅油0.45雙電源內置80761892015/1/6 14:59改良銅散熱片55銦片硅油0.45雙電源內置81751902015/1/6 15:03改良銅散熱片55銦片硅油0.45雙電源內置83781912015/1/6 15:06改良銅散熱片55銦片硅油0.45雙電源內置82771922015/1/6 15:12改良銅散熱片55銦片硅油0.45雙電源內置84771932015/1/6 15:17改良銅散熱片55銦片硅油0.45雙電源

34、內置84791942015/1/6 15:22改良銅散熱片55銦片硅油0.45雙電源內置84781952015/1/6 16:02改良銅散熱片60銦片硅油0.45雙電源內置71721962015/1/6 16:04改良銅散熱片60銦片硅油0.45雙電源內置72761972015/1/6 16:07改良銅散熱片60銦片硅油0.45雙電源內置74771982015/1/6 16:10改良銅散熱片60銦片硅油0.45雙電源內置76761992015/1/6 16:13改良銅散熱片60銦片硅油0.45雙電源內置78782002015/1/6 16:16改良銅散熱片60銦片硅油0.45雙電源內置7876

35、2012015/1/6 16:19改良銅散熱片60銦片硅油0.45雙電源內置80782022015/1/6 16:22改良銅散熱片60銦片硅油0.45雙電源內置79782032015/1/6 16:24改良銅散熱片60銦片硅油0.45雙電源內置79792042015/1/6 16:26改良銅散熱片60銦片硅油0.45雙電源內置79782052015/1/6 16:29改良銅散熱片60銦片硅油0.45雙電源內置81812062015/1/6 16:31改良銅散熱片60銦片硅油0.45雙電源內置死機死機2072015/1/6 17:13改良銅散熱片52銦片硅油0.45雙電源內置7674208201

36、5/1/6 17:15改良銅散熱片52銦片硅油0.45雙電源內置76742092015/1/6 17:18改良銅散熱片52銦片硅油0.45雙電源內置76762102015/1/6 17:21改良銅散熱片52銦片硅油0.45雙電源內置78752112015/1/6 17:23改良銅散熱片52銦片硅油0.45雙電源內置78782122015/1/6 17:27改良銅散熱片52銦片硅油0.45雙電源內置77782132015/1/6 17:30改良銅散熱片52銦片硅油0.45雙電源內置79792142015/1/6 17:32改良銅散熱片52銦片硅油0.45雙電源內置80802162015/1/6

37、17:35改良銅散熱片52銦片硅油0.45雙電源內置死機死機2172015/1/11 13:34改良銅散熱片60銦片硅油0.45雙電源內置83772182015/1/11 13:37改良銅散熱片60銦片硅油0.45雙電源內置85792192015/1/11 13:40改良銅散熱片60銦片硅油0.45雙電源內置84782202015/1/11 13:44改良銅散熱片60銦片硅油0.45雙電源內置83772212015/1/11 13:49改良銅散熱片60銦片硅油0.45雙電源內置83792222015/1/11 13:54改良銅散熱片60銦片硅油0.45雙電源內置85782232015/1/11

38、 13:59改良銅散熱片60銦片硅油0.45雙電源內置84792242015/1/11 14:04改良銅散熱片60銦片硅油0.45雙電源內置85792252015/1/11 14:10改良銅散熱片60銦片硅油0.45雙電源內置84792262015/1/11 14:15改良銅散熱片60銦片硅油0.45雙電源內置84792272015/1/11 14:20改良銅散熱片60銦片硅油0.45雙電源內置84782282015/1/11 14:24改良銅散熱片60銦片硅油0.45雙電源內置84792292015/1/11 14:29改良銅散熱片60銦片硅油0.45雙電源內置84792302015/1/1

39、1 14:34改良銅散熱片60銦片硅油0.45雙電源內置84782312015/1/11 14:40改良銅散熱片60銦片硅油0.45雙電源內置86782322015/1/11 14:46改良銅散熱片60銦片硅油0.45雙電源內置83802332015/1/11 14:51改良銅散熱片60銦片硅油0.45雙電源內置85812342015/1/11 14:57改良銅散熱片60銦片硅油0.45雙電源內置86802352015/1/11 15:04改良銅散熱片60銦片硅油0.45雙電源內置87802362015/1/11 15:09改良銅散熱片60銦片硅油0.45雙電源內置86792372015/1/

40、11 15:14改良銅散熱片60銦片硅油0.45雙電源內置87792382015/1/11 15:20改良銅散熱片60銦片硅油0.45雙電源內置87802392015/1/11 15:25改良銅散熱片60銦片硅油0.45雙電源內置88802402015/1/11 15:29改良銅散熱片60銦片硅油0.45雙電源內置88812412015/1/11 15:33改良銅散熱片60銦片硅油0.45雙電源內置88792422015/1/11 15:39改良銅散熱片60銦片硅油0.45雙電源內置88812432015/1/11 15:46改良銅散熱片60銦片硅油0.45雙電源內置88832442015/1

41、/11 15:52改良銅散熱片60銦片硅油0.45雙電源內置88822452015/1/11 15:57改良銅散熱片60銦片硅油0.45雙電源內置88832462015/1/11 16:04改良銅散熱片60銦片硅油0.45雙電源內置88812472015/1/11 16:11改良銅散熱片60銦片硅油0.45雙電源內置88802482015/1/11 16:16改良銅散熱片60銦片硅油0.45雙電源內置88842492015/1/11 16:21改良銅散熱片60銦片硅油0.45雙電源內置88832502015/1/11 16:30改良銅散熱片60銦片硅油0.45雙電源內置8882CPU0溫度（B

42、）CPU1溫度（B）CPU0溫度（C）CPU1溫度（C）CPU0溫度（D）CPU1溫度（D）CPU0散熱片溫度（A）CPU0散熱片溫度（B）CPU0散熱片溫度（C）CPU0散熱片溫度（D）71716072716757.354.652.354.871726270727156.454.050.453.872736272707056.454.851.954.973736373707157.456.252.155.872746373727258.457.453.656.573756573786859.658.355.557.174736671717760.058.155.657.07377667278

43、7360.258.756.159.274756573797460.159.555.760.075766374797561.059.956.660.076776474807461.560.257.660.776777178807562.060.858.660.876787279817562.460.559.160.876807279827763.261.559.562.577797380827863.362.060.163.077797380837863.362.559.561.778807380847963.862.259.662.079787380死機死機63.162.861.063.375

44、767476797561.559.960.460.575777376807560.660.160.160.87677747782766260.261.063.076787477847561.761.762.063.977777678847562.462.462.564.078797578837663.263.362.564.579797678847863.564.363.365.879807779847864.164.764.566.18081768085776564.664.066.38081788086776664.963.966.5死機死機死機死機死機死機死機死機死機死機80766676

45、7871807767777871807871827972817972838073817972838073807973838072817972838072817973838273828073848373827974898474818073848373838074848374838074858373838174858474848274858474死機死機死機死機死機死機71736770747159.458.756.359.171736772747160.657.656.960.470746770757258.759.856.861.171746669757159.459.656.861.2DELL

46、DELL C6100C6100服服務務器器的的最最高高運運行行溫溫度度測測試試與與優優化化測試數據73756873757261.160.057.561.473756973757159.760.558.361.472756973767259.360.058.061.373756873777461.161.058.962.774777074777362.861.859.862.8死機死機死機死機死機死機死機死機死機死機72736769757161.459.157.061.172746770757162.259.057.361.172746870757262.459.657.662.17274687

47、1757261.961.057.962.372756871767262.561.358.262.472756871767362.761.258.963.172756872757263.261.459.763.872756972767264.161.659.864.472756972777464.561.960.165.1死機死機死機死機死機死機死機死機死機死機67716070737261.157.556.060.467716168737261.257.756.161.168716367747262.559.157.461.668716366747260.358.057.361.66871677

48、1757359.658.257.360.868716770757359.059.857.961.369726772757359.759.658.161.470736872757359.759.858.161.769736772757360.460.259.061.971736872757360.260.159.262.271726872767360.560.958.361.372736872767361.061.158.361.972736973767461.161.458.362.473736972767461.361.558.262.772736973767462.661.058.862.

49、872736973767463.061.559.263.273736972767463.161.159.463.173746873767461.560.759.862.873747074777460.960.760.163.073746973767461.461.260.363.473746973767461.461.460.063.174746973777561.461.760.263.473746973777559.661.460.064.073737073777560.461.760.163.873747074777561.462.360.464.174747074717661.462.

50、460.863.874747074777561.162.561.064.175746974777561.862.559.864.275747174777560.863.260.564.375757075777561.463.360.864.2死機死機死機死機死機死機死機死機死機死機657058.056.5677058.556.6657058.756.8657059.055.8687058.757.0677058.957.5677159.357.7677160.258.1677159.858.1687259.658.6697359.859.0707361.659.1697361.159.4697

51、260.859.4707361.260.1707363.160.6717362.861.0717464.461.4717562.761.6717563.661.4717662.961.8727562.962.0717564.062.0727663.262.2737763.362.3737763.262.8727763.463.0737763.763.4737764.963.4737765.563.9747765.163.7747764.463.7747764.464.2747766.464.1747765.164.4747864.564.5757864.564.4757864.664.6757

52、864.965.0767964.965.3767965.165.6767967.565.8768069.466.1768066.666.4778066.266.7778066.566.8768066.767.0767966.866.9778166.167.3768166.667.4768167.567.3778167.867.5778169.368.4778069.268.8778069.168.1778069.168.2778069.568.4778069.668.570696468686755.956.653.357.671716770686759.359.256.659.97273687

53、2706661.360.657.462.073746873767362.261.157.863.275756873777363.261.157.764.2757570737774死機死機死機死機646659.955.3606560.454.3626561.055.2636762.056.4646763.356.3646864.356.7707365.560.6727567.062.3747668.463.8747769.364.0767969.966.2777870.667.6778072.067.6787971.868.4788272.468.5798274.470.9808474.270.

54、9798475.270.8798275.371.968706371757159.458.356.362.069716472767361.759.657.863.770736473777363.661.358.964.972746875787465.261.960.266.372756875807165.862.560.967.572766976797566.163.261.367.073756876817666.663.762.167.773756877807666.463.662.167.673766877817666.463.862.367.874766977817767.263.962.

55、668.575767077837767.764.563.468.774766978857767.665.363.369.575777178867869.066.364.670.676777079867969.466.264.670.3787772798579死機死機死機死機68726672777262.861.160.264.668736972787364.161.460.565.571756872787364.862.361.566.372767075797565.663.062.267.173766876837566.564.363.367.774766877837667.264.563.

56、568.475786878827668.165.263.769.476787078837868.465.564.369.573787078837868.065.964.869.776787178837869.066.365.270.875797079857769.766.565.771.6死機死機死機死機死機死機死機死機死機死機74747271827465.063.663.067.075747570817465.764.363.267.576747373837465.864.763.868.076757472847466.765.664.568.477767572857567.666.365.

57、369.378767672857567.966.566.070.279777772857668.666.866.170.379787872877769.067.566.671.1死機死機死機死機死機死機死機死機死機死機75787280858068.265.065.769.475787380847968.264.765.569.775787280847968.564.865.770.374787281867968.565.565.570.076797280867969.265.364.870.476807381847969.465.466.171.076797381848069.666.865.

58、570.274807381878070.765.266.470.875807481868170.865.366.270.975807481878170.766.266.371.675807581868069.565.766.772.475807381878170.465.866.771.275817681878171.266.267.271.775817381858271.965.367.571.774817482878172.566.267.571.874817482878272.566.167.571.875807482868071.865.667.771.975817482877971.

59、865.468.071.576817582888272.465.467.874.076827482877972.766.867.872.677827482858272.366.668.472.476837483888373.266.868.772.476837683868372.368.769.073.476837684888372.769.069.873.377837784888474.169.970.075.078837685888373.270.270.875.278847885888573.171.471.073.778847886888473.971.771.875.47985778

60、6888374.471.271.773.979857986888675.870.172.375.878867887878575.470.572.375.579868087888676.070.572.376.479867987888676.371.872.673.080867888888674.772.472.775.3數據分析進油溫度出油溫度進出油溫差Tf-To平均值Tj-Tf平均值綜述39.943.83.911.014.3Tf-To總平均40.243.23.010.516.440.543.83.310.715.010.840.844.94.110.514.9Tj-Tf總平均41.146.2