T35型軸流風機樣本

1、用途T35型軸流通風機是替代30K4型風機的新產品，T35主要是為一般工廠、倉庫、辦公室、住宅等場合的通風換氣或加強暖氣散熱之用，若將機殼去掉，也可作自由風扇，亦可在較長的排氣管道內間隔串聯安裝，以提高管道中的風壓。T35型軸流風機是在國外同類產品的基礎上，通過模型試驗研究，確定了風機葉型，采用了圓筒型輪轂結構，同時對電機進行了改型設計，減少了流動損失，因而使風機效率出口按圓面積提高到77%，按出口環面積計算提高到89.5%,噪聲比A聲降低了3.6dB,又增強了葉根處的強度，避免了葉片斷裂現象。BT35型防爆軸流通風機主要是排送含有易燃、易爆但無腐蝕性之氣體，電機須用防爆電機，開關須用防爆開關

2、或遠離易爆點，在易爆區域內電線不許有接頭。通過T35、BT35風機的氣體應無腐蝕性及顯著粉塵，其溫度不得超40CoBFT35主要是排送易燃、易爆且有腐蝕性之氣體，但溫度不得超過60Co本系列產品按葉輪直徑不同共分為13種機號，依次排列為用2.8、3.15、3.554、4.5、5、5.6、6.3、7.1、8、9、10、11.2等。每一種機號又可安裝成15°、20°、25°、30°、35°等5種角度。本系列產品均采用葉輪直接裝在電動機軸上的直聯結構。在葉輪圓周速度不超過60m/S條件下配用三種轉速：2900、1450、960r/min，面對進風口方

3、向看葉輪為逆時針轉動，進氣方向在葉輪端。風機出廠前，均經運轉試驗，確保運轉平穩。結構T35、BT35風機主要由葉輪、機殼、集風器等三部分組成。BFT35風機主要由葉輪、機殼、集風器等組成，它們均為玻璃鋼制成。支架是由型材制成與風筒連接。葉輪部由葉片和輪轂組成，葉片均采用薄鋼板制成，且按選定之安裝角焊于輪轂上。機殼部由風筒，支架組成，均采用薄鋼板及型材制成，風筒為圓筒型，與葉輪之間有一定間隙。（BT35風機風筒內圓鉚接鋁襯用以防爆）。集風器部由集風器法蘭、集風器組成、集風器為圓弧流線型，可減少氣流入口的損失，由薄鋼板制成。性能及選用性能表中風機性能均指標準狀況（溫度20C,相對濕度50%,大氣壓

4、力101.3xi03Pa,氣體密度1.2kg/m3）的空氣性能。在非標準狀況下工作時須換算成標準狀況下風機性能，再查性能表選取風機機號和轉速。如需改變風機轉速，其性能可按下列公式換算。（m/h）；K(Pa)；ri(kW)如果轉速不變，其性能可用下列公式計算:(m/h)(Pa)(kW)式中：Qp、P、n使用條件下所產生的風量、風壓、主軸功率和轉速;Q、p。、Po、no一標準狀況下選擇的風量、風壓、主軸功率和轉速；t一使用條件下的介質溫度；pi一實際使用條件下大氣壓力（Pa）;J一實際使用條件下的空氣密度（kg/m3）;.Jo標準狀況下空氣密度為1.2（kg/m3）。通風機風量。風壓p、主軸轉速n

5、、軸功率P四者均有固定關系，其中有一數值變更,其它三數值皆受其影響，其變化關系如下：使用安裝維護一、使用采用T35型軸流通風機如需在出風口聯接管道時，必須考慮風機與管道的聯接方式，以減少通風機動壓在接管段因擴散而造成的損失。1）當管道直徑與通風機風筒相等時，管道的擴散損失可忽略不計。2）當叵而管道長度小于管內徑58倍時，可不裝擴散器。3）當叵2.5時，管道與通風機應安裝如圖所示型式之?dāng)U散器。4）當習2.5時，管道與通風機應安裝如圖所示型式之?dāng)U散器。若用在較長的排氣管道內，可將風機間隔串聯安裝，如圖所示。以增高風壓，但兩臺風機不可相隔過遠。風機串聯示意圖安裝轉動二、安裝安裝前應詳細檢查通風機是否

6、因包裝運輸損壞變形，如有損壞變形，待修理后,可進行安裝。安裝時要注意檢查各連接部分有無松動，葉片與風筒間隙應均勻，不得刮碰。連接出風口的管道重量不應由風機的風筒承受，安裝時應另加支撐。在通風機進風口端必須裝集風器，希望裝置防護鐵絲網。風機底座必須與地基平面自然接合，不得敲打底座強制連接，以防底座變形，時應校正機座，加墊鐵片，基本保持水平位置，然后擰緊地腳螺栓。安裝完畢后，必須先進行試驗，待運轉正常后，方可正式使用。三、維修流過通風機的空氣必須清潔干燥，不得混有雜質和過多的水蒸氣。通風機不準吊裝，在長期閑置重新使用時必須檢查各連接部分是否牢固可靠，是否靈活，并經試轉后方可正式使用。經常注意風機在

7、運轉中有無異常聲音，振動是否加大，發現不正常情況時，應及時進行檢修。外形及安裝尺寸機號ABCDEFGHIJKn（）d$d2重量kg2.82833203463552202582122201001752604101210.263.153163553814002402822322402201903008101213.23.553583854224502803272722602102303208101214.2844044504785003003492922902802403708121221.034.54545005285802603142523303102054308121222.93550456

8、058863030036429034041024043012121230.965.656462064971033040431839044026049012121441.346.363469071980039047437844044032054012121457.567.171577080090040049438849063033070016121487.828805860891100048057946855070038077016121890.87990597010011120540648526610810440850161518121.1810100610701103125063075361

9、6670800505956161522151.1611.2112611901223140070088868676010805801289201522192.1注：1.表內重量未包括電動機之重。2.地腳螺栓用戶自備。T35、BFT35M2.8、3.15、3.55、4軸流通風機性能表機號葉輪葉輪主軸葉片風量全壓全壓所需采用配用電機直徑周速轉速角度m/h效率軸功率軸功率型號功率mmm/sr/mindegPa%kWkWkW1512241280.640.0680.078YSF-56220.122017421410.680.1000.115YSF-56320.18042.529002525601430.6

10、90.1470.169YSF-56320.1803024951650.680.1680.193YSF-63220.3502.82803527781860.640.2240.258YSF-63320.37015613320.640.00850.0097YSF-50140.0252087335.20.680.01260.015YSF-50140.02521.5145025113335.70.690.01630.019YSF-50140.02530125141.20.680.02100.024YSF-50240.04035139246.60.640.02820.032YSF-50240.040151

11、944170.10.670.1370.158YSF-63120.180202681186.60.710.1960.225YSF-63220.25047.82900253418189.20.720.2500.288YSF-63320.370303753217.70.710.3200.368YSF-71220.5503.15315354155247.00.670.4250.489YSF-71220.5501597242.50.670.0170.020YSF-50140.02520134046.60.710.0240.028YSF-50240.04023.9145025170947.20.720.0

12、310.036YSF-50240.04030187754.90.710.0400.046YSF-56140.06035207861.70.670.0530.061YSF-56240.090152783216.10.670.2490.286YSF-71120.3702038392370.710.3560.409YSF-71220.55053.92900254895240.30.720.4540.523YSF-71320.7503053752790.710.5870.673YSF-71320.7503.55355355951313.60.670.7700.886YSF-80221.11513945

13、40.670.0310.036YSF-50240.04020192359.20.710.0450.052YSF-56140.06027.0145025245260.20.720.0570.066YSF-56240.09030269269.70.710.0740.085YSF-56240.09035298178.40.670.0950.109YSF-63140.120153980274.30.670.4530.521YSF-71320.75205489300.90.710.6460.743YSF-80221.160.72900256999305.10.720.8240.948YSF-80221.

14711.0641.224YT90S-21.54400358500398.20.671.3841.592YT90L-22.215199368.60.670.0570.066YSF-56240.09020274975.20.710.0810.093YSF-63140.12030.4145025350576.20.720.1030.118YSF-6324050.710.1410.162YSF-6324050.670.1730.169YSF-71140.250T35、BFT35M4.5、5、5.6、6.3軸流通風機性能表機號葉

15、輪直徑mm葉輪周速m/s主軸轉速r/min葉片角度deg風量nm/h全壓Pa全壓效率%所需軸功率kW采用軸功率kW配用電機型號功率kW4.545034.2145015202530352838391449915480606786.895.296.51121260.670.710.720.710.670.1020.1460.1860.2400.3170.1170.1680.2140.2760.364YSF-6314YSF-6324YSF-7114YSF-7124YSF-71240.1200.1800.2500.3700.370550038.01450152025303542895763727379

16、078712112.6124.8129.6145.6164.60.710.750.770.750.710.1890.2660.3380.4260.5610.2170.3060.3890.4900.645YSF-7114YSF-7124YSF-8014YSF-8014YSF-80240.2500.3700.5500.5500.75025.196015202530352839381547925235576849.154.456.863.571.80.710.750.770.750.710.0550.0770.0980.1230.1620.0350.0890.1120.1410.186YSF-802

17、60.3705.656042.51450152025303560258097101681111012239140.9156.1162.6182.12060.710.750.770.750.710.3320.4680.5900.7490.9860.3820.5380.6860.8611.137YSF-7124YSF-8014YSF-8024YT90S-4YT90S-40.3700.5500.7501.11.128.196015202530353989536167327355810361.868.471.379.890.30.710.750.770.750.710.0960.1360.1730.2

18、100.2860.1100.1560.1990.2410.329YSF-80260.3706.363047.814501520253035857911528144771581717426178.3197.6205.8230.5260.70.710.750.770.750.710.5980.8441.0751.3501.7770.6880.9711.2361.5532.044YSF-8024YT90S-4YT90L-4YT90L-4YT100L-40.7501.11.51.52.231.79601520253035568076329585104721153478.286.690.2101.011

19、4.30.710.750.770.750.710.1740.2450.3120.3920.5162.000.2820.3590.4510.680YSF-8026YSF-8026YSF-8026YT90S-6YT90S-60.3700.3700.3700.7500.750T35、BFT35M7.1、8、9、10、11.2軸流通風機性能表機號葉輪葉輪主軸葉片風量全壓全壓所需采用配用電機用直徑mm周速m/s轉速r/min角度degnm/hPa效率%軸功率kW軸功率kW型號功率kW1512280226.50.711.0881.251YT90L-41.52016501250.90.751.5331.76

20、3YT100L1-42.253.914502520722261.40.771.9542.247YT100L2-433022641292.70.752.4542.822YT100L2-437.17103524944331.10.713.233.715YT112M-4415813099.30.710.3160.363YT90S-60.7520109251100.750.4450.512YT90S-60.7536.79602517320114.60.770.5670.652YT90S-60.753014990128.40.750.7130.820YT90L-6120.710

21、.9381.079YT90L-61.11517567287.60.711.9762.272YT100L2-432023605318.60.752.7853.203YT112M-4460.714502529644331.80.773.5484.081YT132S-45.53032389371.60.754.4585.127YT132S-45.588003535682420.30.715.8676.747YT132M-47.51511630126.10.710.5740.660YT90S-60.752015628139.60.750.8080.929YT90L-61.140.29602519626

22、131.10.770.9281.067YT90L-6190.751.2941.488YT100L-61.53523624184.20.711.7031.958YT112M-62.21516560159.50.711.0341.809YT100L-61.52022252176.70.751.4561.674YT112M-62.2990045.29602527944184.10.771.8562.134YT112M-62.23030532206.20.752.3312.680YT132S-633533937233.20.713.0693.529YT132M1-641522

23、7161970.711.752.013YT112M1-62.22030524218.20.752.4672.837YT132S-6310100050.39602538333227.30.773.1433.615YT132M1-643041882254.50.753.9484.54YT160M-67.53546141287.90.715.1975.975YT160M-67.515319142470.713.0853.548YT132M1-642042884273.70.754.3475.000YT132M2-65.511.2112056.39602553855285.10.775.5396.37

24、0YT160M-67.53058841319.30.756.9588.002YT160L-6113564825361.10.719.15810.532YT160L-611BT35M2.8、3.15、3.55、4型防爆軸流通風機性能表機號葉輪葉輪主軸葉片風量全壓全壓所需采用配用電機用直徑mm周速m/s轉速r/min角度degnm/hPa效率%軸功率kW軸功率kW型號功率kW2.828042.529001520253035110215682304224625001221341361571770.640.680.690.680.640.0580.0860.0870.1440.1920.0670.09

25、90.1000.1660.221YBFA-YBFA-YBFA-YBFA-YBFA-631263126312631263220.1800.1800.1800.1800.2521.51450152025303555278610201126125330333439440.640.680.690.680.640.0070.0100.0140.0180.0240.0080.0120.0160.0210.028YBFA-63140.12047.829001520253017502413307633781621771802070.670.710.720.710.1170.1670.2130.2730.135

26、0.1920.2450.314YBFA-YBFA-YBFA-YBFA-63126322633263320.1800.2500.3700.3703537392350.670.3640.419YBFA-71220.550|3.1531523.914501520253035875120615381689187040444552590.670.710.720.710.670.0150.0210.0270.0350.0450.0170.0240.0310.0400.052YBFA-63140.1203.5535553.9290015202530352505345544064838535620522523

27、72652980.670.710.720.710.670.2130.3040.4030.5020.6400.2450.2450.4630.5770.736YBFA-YBFA-YBFA-YBFA-YBFA-711271227122713280220.3700.5500.5500.7501.10027.0145015202530351255173122072423268351566566750.670.710.720.710.670.0270.0380.0550.0630.0830.0310.0440.0630.0720.095YBFA-63140.120440060.72900152025303

28、5358249356299691676572612862903363780.670.710.720.710.670.3880.4030.7040.9101.2000.4460.4630.8101.0501.380YBFA-YBFA-YBFA-YBFA-YBFA-712280228022802290S20.5501.1001.1001.1001.50030.4145015202530351794247431553464383565717284950.670.710.720.710.670.04850.0690.0880.1140.1500.0560.0800.1010.1310.173YBFA-

29、YBFA-YBFA-YBFA-YBFA-631463146314632471140.1200.1200.1200.1800.250BT35M4.5、5、5.6、6.3型防爆軸流通風機性能表機號葉輪葉輪主軸葉片風量全壓全壓所需采用配用電機直徑周速轉速角度nm/h效率軸功率軸功率型r功率mmm/sr/mindegPa%kWkW萬kW152554820.670.090.10YBFA-63140.120203523900.710.110.13YBFA-63240.1804.545034.21450254492920.720.160.18YBFA-71140.2503049321060.710.210.

30、24YBFA-71240.3703554601200.670.270.31YBFA-71240.3701538601070.710.160.19YBFA-71140.2502051871190.750.230.26YBFA-71240.37038.014502565131230.770.290.33YBFA-71240.3703071361380.750.370.42YBFA-80140.55055003578411560.710.420.49YBFA-80240.750152555470.710.050.05203434520.750.660.7625.1960254313540.770.8

31、40.97YBFA-80260.370304712600.750.110710.140.161554231340.710.280.33YBFA-71240.3702072871460.750.400.46YBFA-80140.55042.514502591511540.770.510.59YBFA-80240.7503099991730.750.640.74YBFA-90S41.15.656035110151960.710.840.97YBFA-90S41.1153590590.710.080.95204825650.750.120.1328.196025605968

32、0.770.150.17YBFA-80260.370306620760.750.190.21357293860.710.250.281577211690.710.510.59YBFA-80240.75020103751880.750.720.83YBFA-90S41.147.8145025130291960.770.921.06YBFA-90L41.530142352190.751.161.33YBFA-90L41.56.363035156832480.711.521.75100L1-42.2155112740.710.150.17YBFA-80260.370206869820.750.210

33、.24YBFA-80260.37031.7960258627860.770.270.31YBFA-80260.370309425960.750.340.39YBFA-90S60.75035103841090.710.440.51YBFA-90S60.750BT35Nb7.1、8、9、10、11.2型防爆軸流通風機性能表機號葉輪葉輪主軸葉片風量全壓全壓所需采用配用電機直徑周速轉速角度效率軸功率軸功率型號功率用mmm/sr/mindegm/hPa%kWkWk710.931.07YBFA90L41.520148512380.751.311.51100L1-42.253.9145025186502480.771.671