輻照交聯低煙無鹵阻燃聚烯烴

1、輻照交聯低煙無鹵阻燃聚烯炷電纜料Irradiation cross-linked, low-sinuke9 halogenfree and flameretardant POE compound1.產品型號.用途i. Type and application牌號Type名稱Product用途及電纜規范Application and Cable SpecificationFDW1105105*C輻照交顒氐煙無鹵阻燃聚烯炷電纜料 105 °C Irradiation cross-linked, iow-smoke, halogen-free and flame retardant POE

2、 compound105*C交聯阻燃電線電纜用絕緣、護層料105 °C Insulatmg and jacket for cross-linked flame retaidant wires and cables.FDU2125125°C輻照交聯低煙無鹵阻燃聚烯炷電纜料125 °C Irradiation cross-linked, low-smoke, halogen-free and flame retardant POE compound125#C交聯阻燃電線電纜用絕緣、護層料125 °C Insulating and jacket for cro

3、ss-linked flame retaidant wires and cables.FDW1150i5(rc輻照交聯無鹵阻燃聚烯桂電纜料150 °C Irradiation cross-linked, low-smoke. halogen-free and flame letardant POE compound150°C交聯阻燃電線電纜用絕緣、護層料150 °C Insulating and jacket for cross-linked flame retaidant wires and cables.FDW5105105-125X輻照交聯低煙無鹵高阻燃聚烯

4、炷電纜 料105 eC Irradiation cross-linked, low-smoke, halogenfree and flame retardant POE compound105-125°C交聯阻燃電線電纜用絕緣、護層料， 特小規恪電線通過VW-1阻燃105 °C Insulating and jacket for cross-linked flame retaidant wires aud cables. The very small grade wires could pass VW1 standard2. 產品tttg耐高溫輻照交聯低煙無鹵阻燃聚烯炷電纜

5、料是以聚烯炷樹脂為基料，加入特殊改性劑、無鹵阻燃劑、抗氧劑、交 聯敏化劑等其他特殊助劑，經特殊工藝加工而制得的粒狀料.ii% High temperatuie resistive, irradiation cross-linked, low-smoke, halogen -free and flame retardant POE compound, based on POE resin, is produced and pelletized by special technclogy with addmg special modifier, haiogen-fiee flame retaida

6、nt, anti-oxidant, cross-linked sensibilizer and other special additives.3、加工工藝 采用F擠出機加工,建議使用L D> 20、壓縮比1 : 1.2的低壓縮比螺桿。iiiv ProcessingThe compound can be processed with conventional extniders. and ±e screw with a mimmum 20:1 L D and a compression ratio of 1.2 is recommended.推薦擠出機各區點設走溫度如下：The

7、 following【empemniie(°C) piofile of extrudei is recommended區點Zone1區Zone 12區Zone 23XZone 34區Zone 4機頭Head模頭Die溫度 temperature °C90110125140145145注：如杲材料在倉庫存儲二個月以上,請將材料在60-70X下干燥后在使用。Note : Compound should be dried at 70-80°C before use. which has storage time exceedmg two months.4、棚腳僵耐高溫輻

8、照交聯氐煙無鹵阻燃聚烯炷電纜料的輻照刑建議一般為13兆拉律。iv% Irradiated dosage The normal uradiated dosage ( recommended ) of high temperatuie resistive. irradiation cross-linked, lowsnioke. halogen-free and flame retaidant POE compound is 13 megaiad.5、包裝：25kg-袋f鋁塑復合薄膜抽真空內袋,牛皮紙復合袋外包裝。運輸與儲存:電纜料在運輸過程中不應受日曬雨淋,應儲存在清潔、陰涼、干燥、通風的倉庫內

9、。V% Storage and transportPackaging : 25kg. bag f Vacuum Aluminum foil and PE membrane mside bag. and kraft outside bag.Storage and uansport: Avoiding in duect sunlight and weathering The storage place should be in clean, cool, diy and ventihted conditions.6.產品ttfg （換）Vl% Properties表 Table試驗項目 Item卑位

10、 UnitFDVVU05FDW2125FDW1150FDW5105標準值 Standard典型值 Typical標準值 Standard典型值 Typical標準值 Standard典型值 Typical標準值 Standard典型值 Typical比至 Densitygcm1.46 1.46 1.44 1.65硬度HardnessShore A 94 949286抗拉強度 Tensile Stiength> MPa10015010011.010012.57.0100斷裂伸長率 Elongation at Break> %150170150200150180100130熱老化 Th

11、eimal Aging老化溫廈Aging Temperatxue°C135±2135±2158±2158±2180x2180x2135±2158x2老化時間 Aging Timeh1681681681681681681681687FSLetention of trengtliV7Tensile> %80104801088011080104呆群RetentionofElongation at Break2 %80103809580868095熱延伸：20N/cm- Thermal Prolongation°Cxnim20

12、0x15200x15200x15200x15載荷卞伸長率 Elongation Under Load< %17525175251752517525永久變形率 Permanent DeformationS %15515015515520°C體積電阻率 Volume RMistivity. at 20°C> O . mlOxlO1240xl01:1 Ox IO12OxlO12lOxlO1290xl0l:lOxlO12OxlO12介電強度 Dielectric Stiength> KV inm20242024202420261C111計旨數 Jxygen Index> %2832283228334547氐溫脆化溫度 mpact Brittleness emperatuie°C-25通過Pass-25通過 Pass25通過Pass-25通過Pass煙密度有焰 Smoke Density Flaming<10065100601006810045無焰 Non flanung<20014520014020015020095e