噴霧船的結構設計如下所示

1、HF35D/35機器生產規格參數定單 Manufacture specification order formHF35D/35改進規格參數說明HF35D/35 improvement specification explanation機器改進編碼說明Improvement Code (IC) explanationIC-0: 標準化設計: 同一機型必須保持前后設計參數的一致性，改進項目除外 Identical design: Excepting improvement items, same model have to have identical specifications with di

2、fferent orders.IC-1:抗化學品腐蝕措施:任何與化學品接觸的塑料部件要使用HDPE材料或抗化學品材料, Chemical resistance measures: Any parts contacted with chemicals should be chemical resistance materials.IC-2(新NEW): NEMA和CE標準 所有電器部件要符合美國的NEMA和歐洲的CE標準，NEMA and CE standards:All of the electric parts need to meet with American NEMA and Euro

3、ps CE standards.IC-2.1: 電路接口防爆防腐保護:所有的電器電線接頭都要有防爆防腐保護措施。如這次的按鈕失靈，可能與此有關.措施是更換施耐德按鈕 Wire connection protection:All of electric connection should have explosive proof devices. For example, the malfuction of control button might be related to the reason. The solution is Replaced with Schneider bottomIC

4、-2.2:線路線頭保護:電線出口，如化學箱出來的電器接頭，還有柴油機與控制箱的電線和其它接口都要有金屬蓋板或合適的保護措施。All low water sensors, and other through tank fittings shall have a metal cover to protect the electrical connection points from being damaged IC-2.3(新NEW): 所有的連接管和閥門: 所有的管子不能用塑料管連接，除非是HDPE硬管.All piping cannot have plastic joints unless t

5、he plastic is HDPE, including all plastic valves. IC-2.4(新NEW):考慮霧炮單元可拆卸方便，采用一根線從元件一直到電器箱，中間無接頭連接；For being easy to disconnect cannon, only use one cable directly connect to the control box without any extra connection between the connon and control box.IC-3:防銹問題:所有的鋼管的末端都要封死，不讓濕氣進入以免銹從內生。Rust preve

6、ntion: All steel tubing shall have the ends capped so that moisture cannot get in and begin to rust steel IC-3.1:防銹問題:油漆必須有噴砂-底漆-面漆的過程，今后，我們可能要用聚脲樹脂新技術來做漆。在安裝任何部件前，鋼架必須先上好防銹漆和油漆。Rust prevention: All steel tubing and parts shall be primed and painted prior to the mounting of any equipment. IC-3.2(新NE

7、W):鋼架的空心開口要封掉，防止水氣進入生銹 The open of the steel frame have to be closed to prevent from rust inside.IC-5(新NEW):出水過濾器(80微米/200目的過濾器)必須裝在水箱出水口附近，注意，過濾器一定要垂直安裝，并有擋板保護。Water filter: (80Micron/200 mesh) have to be installed vertically and protected by steel plate.IC-6(新NEW):水箱充水問題:水箱充水設在水箱的底部,并要配備閥門和快接接頭。注意

8、: 充水口與出水口在同一高度，離底部都要有50 mm距離，防止水中的雜質流入系統，Water filling problem: Water tank filling open is set at bottom of the water tank and shall have a valve and quick filler connection. Attention: the height of inlet and outlet of water should be same and is around one inch to prevent sediment particles gettin

9、g into system. IC-7: 柴油機相關的問題: 如排氣管的彎頭罩，調節閥彈簧配件，儀表盤的面板蓋，的問題等 Deisel related problems: curve exhaust fitting, adjustment valve spring parts, panel cover, low fuel level shut off system，burn oil problem etc.IC-7.1: 柴油機運行計時器:新的柴油機增加了頻率表和運行時間計時器，計時器是一個4位的數碼管。The new diesel engines have increased frequen

10、cy indicator and Engine hour meter.IC-7.3(新NEW):柴油機功率不夠大，改成10-15KW稀土風冷柴油發電機. 電壓頻率參看電機 The diesel need to be expanded to 10KW-15KW rear earth Air cooled generators and the voltage and frequency refer to the electric motors.IC-7.4(新NEW): 增設柴油機低油位自動熄火系統 Increase a new function to shut down the diesel w

11、hen the fuel level is low. IC-8: 梯子系統: 機器將要有一個梯子系統讓工人能接近噴嘴來更換和清洗 ladder system: The machine will have a ladder and platform for worker to be able to access, clean and change nozzles on misting cannon as per de-sign 。IC-9.1/IC-7(新NEW): 設備軟件改進-1/柴油機定時保養報警系統: (托尼認為此功能不重要，最好不要，但柴油機是否有總運行時間記數表，象汽車的總里程表一樣

12、，即可Software improvement-1/Diesel regular maintenance alarm system: This function can be eliminated as long as the diesel has operation time counter.IC-9.2(新New): 不再設定M1M2M3M4等等工作定時的模式，暫時統一為工作30分鐘，停10分鐘；客戶有特殊需求，工作時間在出廠時，根據其要求更改 Eliminating Mode M1M2M3M4to make a identical working pattern as working f

13、or 30 minutes and resting for 10 minutes.功能鍵如下所示 The function buttons are shown below:上排 Up rowM1M2左四分之一Left Quarter 右四分之一Right Quarter 手動/自動 Manual/Auto.下排 Down row啟動 Start停止 Stop水平 Horizontal 垂直 Vertical急停 Emergency stopIC-9.3(新New): TONY要求所列的五種旋轉控制模式均要實現；即：水平180；垂直70（實際只能達到70度）；水平加垂直；左四分之一圓；右四分之一

14、圓；The machines have to have five rotation models that are horizontal 180 degree, vertical 70 degree; horizontal plus vertical; left quart circle; and right quart circle.IC-9.4(新New): 根據討論，報警器還是要保持！用于低油位停機或過載停機，低水位停霧炮頭報警。Alarm system still need to be kept to stop diesel when the fuel level is low or

15、overload or the cannon when water level is low.IC-9.5(新New): 紅外自動啟動,為附加功能,HF-35,HF-35D均有此項功能.在儀表盤上,此按鈕為雙相選擇按鈕,即,一邊是手動,一邊是自動;當按鈕撥在手動側,霧炮只能通過按鈕或遙控啟動,紅外感應不起作用; 當按鈕撥在自動側,只要霧炮有電,當有垃圾車經過觸發紅外線時,霧炮將自動啟動,工作時間為10分鐘;如果10分鐘內,無垃圾車經過,則10分鐘后, 霧炮停止,直到下次觸發;如果在10分鐘內,有垃圾車經過,則計時將被置零,重新計時.這樣的話,如果在高峰時期,霧炮將會連續工作,又不會反復啟動.I

16、C-11(新New): 高壓泵相關問題: 如泵與電機不配，密封墊無抗化學藥性(孫總已做過試驗，原來高壓泵的密封墊全部不是抗化學藥品的。不知你們是怎么改進的，請溝通這一問題的處理方法)。 Problems from high pressure pump. For example, non match between pump and motor and non chemical resistance with the seals.IC-12(新New): 電機相關問題: 電壓220v,50hz,三相(歐洲，澳洲)60HZ (美國，加拿大)Problems related to electric

17、motors: voltage (220v,50hz,3PH for Europe and NZ; 60hz for USA and CAN.)IC-12.1:電機過濾器: Air Filter of electric motors. IC-12.2(新New): 高壓泵電機功率不夠，由0.75KW改1.5KW. The power of pressure pump motor is not enough and need to be upgraded to 1.5KW.IC-13: 控制箱相關問題: Problems related to control boxIC-13.1: 控制箱的散熱

18、問題: Heat releasing problem for control boxIC-13.2(新New): 遙控: 托尼建議只需要啟動和停止設備(柴油機和霧炮頭)的功能；旋轉控制無需遙控，都采用手動控制；Remote only keep four keys: two for start diesel and fan and two for cannon. IC-14: 水路，管路連接和閥門問題 Water flow, Pipe Connection and valve problemsIC-14.1(新New): T形過濾器必須垂直安裝，并有擋板保護; 要把原配比泵后的Y型過慮器取掉，因

19、它會增回壓力，因我們已有一個T型過濾器裝在了原配比泵的前面。The banana filter must stay in its place and counting meter must be mounted vertically as we did on the machines at LaoGong; The Y filter has to be eliminated from the pipe because it will increase some pressure and we have had a T filter installed front of the dosatron

20、.IC-14.2(新New): 取消所有機器的配比泵,裝一個不少于60升的塑料箱，并標上刻度，請看具體的設計圖(它有圓錐形或棱形的底) ，用一個硬管使之與大水箱相連(水箱邊上打一個孔來連接)。Eliminate the dosatron on all machines.Mount a 20 gallon or 75 liter plastic tank with conical or prism shaped bottom with place to put tubing that can be attached to a hole in the side of the large tank；

21、IC-14.3(新New): 機器上要配一個固定的盒子用來裝所有型號的噴嘴，還要有備用噴嘴配備。增加7號噴嘴。We should have a box permanently installed on the machine to hold nozzles. Need #7 nozzles.IC-15: 升降系統問題: problems of lifting systemIC-17: 可拆卸式支撐架(請看具體的設計圖): Detachable support frame for shippingIC-16.1: 裝運用疊裝支撐腳(請看具體的設計圖): Support legs for over

22、 load of the frame with diesel on that.紅外自動啟動:IC-16.2: 叉車起重設施: 在底座底部 ，要有供叉車從側面插入的方鋼管,方便叉子插入來搬動機器。(注意叉子距離和方管的位置以空載重心為準)Fork lift pocket: Need to have fork lift pocket where forks can fit in. HF35/35D型機器的控制說明:霧炮單元控制Fan Unit Controls:單元開關On-off switch for fan unit高壓泵開關(控制它必須在單元開關開啟后才能被開啟)On-off switch

23、for hi pressure water pump (wired so that this switch cannot be turned on until fan unit fan is on)單元轉頭控制(5個選擇)Fan Rotation Control: (five options)1.僅180度水平轉頭180 degree horizontal only path2.僅180 度垂直轉頭degree through vertical only path3.180度水平轉頭，然后180 度垂直轉頭180 degree horizontal and then 180 degree ve

24、rtical path4.左四分之一圓運動軌跡: 中心水平90度到左水平，到中心垂直，再回到中心水平left quadrant (90 degree only) center horizontal to left horizontal to center vertical and back to center horizontal5.右四分之一圓運動軌跡: 中心水平90度到右水平，到中心垂直，再回到中心水平Right qua-drant (90 degree only) center horizontal to right horizontal to center vertical and b

25、ack to center horizontalHF-35的另加說明:霧炮單元開關控制Fan on off Controls1. 這是唯一的一個設置，這就是什么時候控制器把高壓水泵打開。只有當霧炮打開時，高壓水泵才能被打開。There is only one setting and that is when the controller turns high speed water pump on.The high speed pump can be only turned on when the cannon has been turned on. 控制開關的位置Location of Co

26、ntrol Buttons:1. 要求有一個小的控制盒與霧炮單元分開，控制盒用至少40英尺的電纜與霧炮單元相連來控制所有的電器部件，還有相當長的電源線給霧炮單元供電。A control box should be separate from the Fan and misting cannon. The separation can be created by either a 40 ft cord that provides the power lines, along with the water line to the misting fan head to control the el

27、ectric motors for the high pressure pump, the fan motor, and the motors that drive the rotation of the misting fana. 連接電纜兩頭要有插頭與霧炮單元和控制盒相連?？刹宕驌?。The cable running from the fan head to the control panel should be able to be unplugged (specifically have plugs at each end that fit into the fan head and

28、to the control panel)b. 電纜的長度應適合不同的情況。There should be additional cables for different cases.注意，霧炮單元有可能放在屋外，房頂，油桶頂部等，控制盒是在室內或地面，以便人能在地面上控制。所以電纜的長度要考慮這一因素。NOTE: This concept is important when the fan unit is located on the side of a building, in a transfer station, or on a top of a oil tank. The contr

29、ol panel needs to be able to be located near the ground so the fan can be con-trolled from where someone can stand on the ground2. Connection points for CATV cables for central control of fan from a central computer using software for controlling on and off, fan unit direction, and other controls. 用

30、于軟件從中心計算機來控制霧炮單元的開關，轉頭和其它控制的連接點。HF35D/35定單及參數表 HF35D/35 Specification and order form金額1: 不再有用的配件 Cost1: The old parts that have no use any more金額2: 可再有用的配件或新購置的配件Cost2: The old parts that can be used or new purchased parts定單信息Order information數量 No.金額1 Cost1金額2 Cost2備注 Remark(填寫廠家，型號等)美國和加拿大USA/CAN

31、英國UK 新西蘭NZ美國USA加拿大CAN型號 ModelsHF35DHF35DHF35DHF35DHF35HF35定制數量 Order amount(IC-0)同一機型必須保持前后設計參數的一致性，改進項目除外Please keep identical specifications 454431優先級 Priority要得最急9臺It is most urgent 144交貨時間 Deadline請?zhí)峁┙回洉r間Please provide deadline霧炮單元 Hurricane unit(包括不銹鋼箱體，Including the stainless steel box )風扇體 Fa

32、n body 1Weight重量220kg風扇電機 Fan motor轉頭電機 Rotation motors123KW2*0.12KW220V,60HZ，三相 3PH；220V,50HZ，三相 3PH；220V,60HZ，單相 1PH；575V,60HZ,三相 3PH；高壓泵電機 Pressure Pump motor(IC-12.2)1.5KW220V,60HZ，三相 3PH；X220V,50HZ，三相 3PH；220V,60HZ，單相 1PH；575V,60HZ,三相 3PH；噴頭 Nozzles (IC-14.3) 每種型號數量Amount:10, Model型號 #4，#5，#6,#

33、7(增加7號)X高壓泵High Pump 1(IC-1) 更換成含HDPE墊片X高壓泵壓力表meter of the high pump 1X定單信息Order information數量 No.金額1 Cost1金額2 Cost2備注 Remark美國和加拿大USA/CAN 英國UK新西蘭NZ美國USA加拿大CAN3+1(35D)5(35D)4(35D)4(35D)3(35)1(35)高壓水管 pressure water pipes(IC-1) HDPE 或其它耐化學品材料 HDPE or other chemical resistant materialsX供水系統 Water supp

34、ly system水箱 Water tank 1(IC-1)HDPE 或其它耐化學品材料(Size直徑:1300 mm，hight高度1800mm, Volume體積 2000L升, Material料質:HDPE, thickness厚度: 7.5mm).XXXX快接充水系統 filler pipe with a quick disconnect fitting1(IC-6) 請看上面相應的改進描述. Please check above code description.XXXX截止閥 Stop valve1(IC-14)XXXX水箱出水過濾器 Water filter1(IC-5)出水過

35、濾器(80微米/200目的過濾器)80Micron/200 mesh water filterXXXX過濾器檔板:Panel for Filter 1(IC-14.1)過濾器必須垂直安裝在檔板上，并靠近水箱的位置。Filter shall be vertically mounted on flat steel plate mounted close to the water tank. XX低水位補水探頭 Low water level sensor1XXXX供藥液系統 Chemical supply system藥箱 Medical tank1(IC-14.2)HDPE 75L升錐形底XX藥

36、箱加熱器 Heater(IC-14.2)取消 EliminatedXXXXXX藥箱攪拌器 Stirrer(IC-14.2)取消 EliminatedXXXXXX藥箱攪拌器小電動機 Agitator motor(IC-14.2)取消 EliminatedXXXXXX藥箱低水位感應器Chemical tank sensor(IC-14.2)取消 EliminatedXXXXXX蜂鳴器 Buzzer 1用于補柴油，補水、故障等的報警 for low fuel, low water level or malfunction alarmXX流量計 Flow meter1磁流汁 Magnetic read

37、er typeXX傳輸管道 Pipes (IC-1)HDPEXX化學配比注射系統(白色) Dosatron (IC-14.2)取消EliminatedXXXXXX管路加熱系統 Pipe heating system(IC-4) 取消EliminatedXXXXXXPower system 動力系統風冷式柴油機:Diesel engine (重新購買）17220V,60HZ，三相 3PH；XX220V,50HZ，三相 3PH；(IC-7.3) 10-15 KW，它將要滿足15小時連續運行的要求。That will be designed for 15 hour continuous runnin

38、g(IC-7.2)改水冷裝置(如用上面大功率的風冷，水冷裝置應沒有必要了) It doesnt need water cooled device if using big generators.(IC-2) 柴油機要符合美國的NEMA和歐洲的CE 標準 The diesel needs to meet with American NEMA and Europes CE standards.柴油機運行總計時器:Engine hour meter.(IC-7.1)頻率表和運行時間計時器， Frequency indicator and Engine hour meter.XX柴油機電子點火器:Di

39、esel ignition 點火器由柴油機自身配備 this device comes with diesel engineXXFoundation system 支撐系統底座 Platform1(IC-16.2)要有供叉車從側面插入的方鋼管,方便叉子插入來搬動機器Need to have fork lift pocket where forks can fit in.XX立柱 Vertical post2用于支撐升降系統。為方便裝運，立柱要可拆卸式 For shipping, the post that support the lifting system, have to be detac

40、hable. XX升降支架 Support frame1用于支撐霧炮體，并能升降高度。為方便裝運，支柱要可拆卸式 For shipping, the frame that support the cannon have to be detachable. XX船體 Boat 1取消EliminatedXXXXXX梯子系統 Ladder to access nozzles 1(IC-8)梯子系統可讓工人接近噴嘴來更換和清洗 The ladder let worker access, clean and change nozzles.XX平衡桿 Balance steel stick4可加寬底座的

41、寬度，以在垃圾場為機體保平衡。(取消Eliminated)XXXXXX平衡桿支撐腳 Support legs4螺紋絲桿(取消Eliminated) XXXXXX升降系統:Lifting sys.手動液壓泵站 Manual hydraulic system1XX液壓油缸 Hydraulic cylinder1按原設計Keep original designXX高壓油管 Oil pipes按原設計Keep original designXX電器部分 Electric partsNEMA和CE標準NEMA and CE standards.(IC-2)所有電器部件要符合美國的NEMA和歐洲的CE 標

42、準 All electric parts need to meet with American NEMA and Europs CE standards.電線接頭保護: Elec. connections (IC-2.1)要有防爆保護措施。Explosive proof devices needed.電線出口接頭保護Elec. outlet (IC-2.2)出線口線頭都要有保護措施，如柴油機與控制箱的電線接口。All electrical connection has to have physical protection design. 控制系統 Control system 操作平臺(HF35)Operating platform1控制盒與霧炮單元分開用于地面控制，控制盒用至少40英尺的電纜和水管與霧炮單元相連用于控制，供電和供水。A control box should be separate from the Fan and misting cannon for ground control. A 40 ft cord and water hose that provides control, pow