全英文)建筑施工基坑開(kāi)挖的安全防護(hù)Excava.ppt

OSHA Office of Training and Education,1,Excavations,OSHA Office of Training and Education,2,Excavation Hazards,Cave-ins are the greatest risk Other hazards include: Asphyxiation due to lack of oxygen Inhalation of toxic materials Fire Moving machinery near the edge of the excavation can cause a collapse Accidental severing of underground utility lines,OSHA Office of Training and Education,3,Injury and Death,Excavating is one of the most hazardous construction operations Most accidents occur in trenches 5-15 feet deep There is usually no warning before a cave-in,OSHA Office of Training and Education,4,Definitions,Excavation a man-made cut, cavity, trench, or depression formed by earth removal. Trench a narrow excavation. The depth is greater than the width, but not wider than 15 feet. Shield - a structure able to withstand a cave-in and protect employees Shoring - a structure that supports the sides of an excavation and protects against cave-ins Sloping - a technique that employs a specific angle of incline on the sides of the excavation. The angle varies based on assessment of impacting site factors.,OSHA Office of Training and Education,5,Focus of Training,The greatest risk at an excavation How to protect employees from cave-ins Factors that pose a hazard to employees working in excavations The role of a competent person at an excavation site,OSHA Office of Training and Education,6,Protection of Employees,Employees should be protected from cave-ins by using an adequately designed protective system Protective systems must be able to resist all expected loads to the system,OSHA Office of Training and Education,7,Requirements for Protective Systems,A well-designed protective system Correct design of sloping and benching systems Correct design of support systems, shield systems, and other protective systems Plus Appropriate handling of materials and equipment Plus Attention to correct installation and removal Equals Protection of employees at excavations,OSHA Office of Training and Education,8,Design of Protective Systems,The employer shall select and construct : slopes and configurations of sloping and benching systems support systems, shield systems, and other protective systems Shield - can be permanent or portable. Also known as trench box or trench shield. Shoring - such as metal hydraulic, mechanical or timber shoring system that supports the sides Sloping - form sides of an excavation that are inclined away from the excavation,OSHA Office of Training and Education,9,Protect Employees Exposed to Potential Cave-ins,Slope or bench the sides of the excavation, Support the sides of the excavation, or Place a shield between the side of the excavation and the work area,OSHA Office of Training and Education,10,Cave-in Hazard,This excavation has inadequate support posts and egress access,Inadequate protective system,OSHA Office of Training and Education,11,Inadequate Protective System,OSHA Office of Training and Education,12,Factors Involved in Designing a Protective System,Soil classification Depth of cut Water content of soil Changes due to weather and climate Other operations in the vicinity,OSHA Office of Training and Education,13,Shoring,General Provides a framework to work in Uses wales, cross braces and uprights Supports excavation walls OSHA tables provide shoring data Must know soil type Must know depth and width of excavation Must be familiar with the OSHA Tables,OSHA Office of Training and Education,14,Trench Shield,A trench shield was built around this work area,OSHA Office of Training and Education,15,Hydraulic Trench Support,Using hydraulic jacks the operator can easily drop the system into the hole Once in place, hydraulic pressure is increased to keep the forms in place Trench pins are installed in case of hydraulic failure,OSHA Office of Training and Education,16,Materials and Equipment,Equipment used for protective systems must not have damage or defects that impair function. If equipment is damaged, the competent person must examine it to see if it is suitable for continued use. If not suitable, remove it from service until a professional engineer approves it for use.,OSHA Office of Training and Education,17,Protection from Vehicles,Install barricades Hand/mechanical signals Stop logs Grade soil away from excavation Fence or barricade trenches left overnight,OSHA Office of Training and Education,18,Hazardous Conditions,The weight and vibrations of the crane make this a very hazardous condition. They should not be working under this crane.,OSHA Office of Training and Education,19,Spoils,Dont place spoils within 2 feet from edge of excavation Measure from nearest part of the spoil to the excavation edge Place spoils so rainwater runs away from the excavation Place spoil well away from the excavation,OSHA Office of Training and Education,20,Other Excavation Hazards,Water accumulation Oxygen deficiency Toxic fumes Access/Egress Falls Mobile equipment,OSHA Office of Training and Education,21,Water is Hazardous,When water is present in an excavation it is extremely hazardous to enter,Note that these workers are not wearing hardhats to protect them from materials falling into the trench,OSHA Office of Training and Education,22,Water = Cave-in Hazard,These workers must be protected from cave-in. Note the water in the bottom of the trench. This is a very hazardous condition!,OSHA Office of Training and Education,23,Hazardous Atmosphere,Test excavations more than 4 feet before an employee enters the excavation for: Oxygen deficiency High combustible gas concentration High levels of other hazardous substances,OSHA Office of Training and Education,24,Means of Egress,A stairway, ladder, or ramp must be present in excavations that are 4 or more feet deep, and within 25 feet of the employees,This ladder does not meet the requirements of the standard,The ladder should extend 3 feet above the excavation,OSHA Office of Training and Education,25,Access and Egress,These two ladders which are lashed together are not an adequate means of egress The ladder should extend 3 feet above the top of the excavation,OSHA Office of Training and Education,26,Protection from Falls, Falling Loads, and Mobile Equipment,Install barricades Use hand / mechanical signals Grade soil away from excavation Fence or barricade trenches left overnight Use a flagger when signs, signals and barricades are not enough protection,OSHA Office of Training and Education,27,Competent Person,Must have had specific training in and be knowledgeable about: Soils classification The use of protective systems The requirements of the standard Must be capable of identifying hazards, and authorized to immediately eliminate hazards,OSHA Office of Training and Education,28,Inspections of Excavations,A competent person must make daily inspections of excavations, areas around them and protective systems: Before work starts and as needed, After rainstorms, high winds or other occurrence which may increase hazards, and When you can reasonably anticipate an employee will be exposed to hazards.,OSHA Office of Training and Education,29,Inspections of Excavations,If the competent person finds evidence of a possible cave-in, indications of failure of protective systems, hazardous atmospheres, or othe