一、垃圾分選系統

1、精選優質文檔-傾情為你奉上一、垃圾分選系統垃圾分選，歷來是垃圾處理技術的瓶頸，不管是焚燒、填埋處理工藝，還是綜合處理工藝，很多失敗案例都是因?yàn)槔诌x不徹底，導致下工序無法處理而使整條生產線都不能正常運行。城市生活垃圾“LJ”五化處理技術-垃圾分選系統，是該技術的核心，該系統通過垃圾均勻給料、大件垃圾自動分選系統、大件垃圾破碎系統、袋裝垃圾自動破袋、大塊有機物自動破碎系統、全封閉機械化風選系統、塑料水選系統、有機物高溫高壓水解水熱氧化“熱選”系統等工藝處理后，可將城市生活垃圾分選為： 1) 無機物類； 2)砂土類； 3) 有機物類； 4) 不可回收可燃物類（若輔以簡單人工分選，還可以分出硬質塑

2、料、橡膠等）； 5) 薄膜塑料類； 6) 鐵磁物類.以上垃圾，分選純度均可達到85%以上，薄膜塑料分選純度可達到90%以上，為下工序垃圾處理的“資源化、產業化”打下了堅實的基礎?；旌鲜抢?，分類是資源。Waste Sorting System Waste separation has always been the bottleneck of waste disposal technology, whether incineration, landfill treatment process, or integrated treatment process. Many failures are

3、 due to garbage sort not complete, leading that the next process can not handle, and the whole production line can not run properly. Municipal solid waste “LJ” Five treatment technologies- the core technology of the waste sorting system, is the key technology. By garbage uniform feeding, automatic s

4、orting system of bulky waste, bulky waste automatic crushing system, automatic torn bags of garbage bags, bulky organic matter automatic broken system, closed mechanization winnowing system, plastic water selection system, and “hot election” system of high temperature and pressure of hydrothermal hy

5、drolysis of organic matter, urban house refuse can be separated to many kinds: 1) inorganic; 2) sands; 3) organic; 4) irrecoverable fuel (if supplemented by simple manual sorting, hard plastic and rubber etc will be separated); 5) film plastic; 6) ferromagnetic materialsThe sorting rate of the above

6、 garbage can reach more than 85%, the sorting rate of film plastic reaches more than 90%, lay a solid foundation for next treatment of “Resource and Industrialize”Mixing is Rubbish, while Classifying is Resource二、有機物高溫高壓水解水熱氧化制肥系統該系統是“LJ”五化處理技術的核心技術之一，前處理系統分選出來的有機物,經高溫高壓水解水熱氧化釜在溫度193°C、壓力1.25Mp

7、a的條件下，反應2小時，徹底消滅了病蟲害和雜菌，并使有機物中的大分子鏈斷成易于農作物吸收的小分子鏈，由于有機物在高溫高壓反應過程中，產生了大量的糖分和腐殖酸，所以該肥料養分充足，是綠色食品的必用肥料。根據市場需求，配入其它養分即可生產出各種高效有機無機復混生態農作物專用肥。以有機物為主的垃圾，經過2個小時左右的“水解”處理后，其中，95%以上的有機垃圾在水解噴爆過程中被膨化成棕褐色粉末，降解為有益于農作物生長的優質有機肥，然后經過烘干、篩分，把有機質粉末與其它未降解物徹底分離。該工序能將不可降解的無機物與有機物徹底分選開來，所以也叫“熱選”。該工序所需熱能來自焚燒系統的余熱鍋爐，能源循環利用，

8、以垃圾處理垃圾，大大地降低了垃圾處理成本。高溫高壓水解水熱氧化技術的作用：1, 把大分子鏈斷為短分子鏈。2, 加速糖類、腐殖酸的轉換，提高有機肥的質量。3, 滅菌徹底，完全實現了無害化處理。 Organic High Temperature and Pressure Hydrolysis and Oxidation Composting System The system is the core technology in “LJ” Five technologies, organic sorted out of pre-treatment system, in hydrothermal hy

9、drolysis oxidation reactor, with 193,1.25Mpa,the react for 2 hours, completely eliminate pests and bacteria, and make the macromolecular chain in organic matter broken into easily absorbed by crops small molecules chain. Due to lots of sugar and acid generated from the high temperature and pressure

10、reaction process of organic matter, the fertilizer is nutrient adequacy, and a must fertilizer to green food. According to market demands, it can be blended with other nutrients to produce a variety of organic and inorganic specific ecological compound fertilizer for crops. The garbage dominated by

11、organic waste, after about 2 hours “hydrolysis” treatment, more than 95% organic waste of them were extruded into brown powders during the hydrolysis jet explosion process, and degrade to quality organic fertilizer benefit for the growth of crops. And though drying and screening, absolutely separate

12、 organic powders and other undegraded matter. This process can completely separate the undegraded inorganic waste and organic waste, so called “hot election”. The heat required by this process from the waste heat boiler system can recycle, use waste to dispose waste, will greatly reduce the waste di

13、sposal costs.The role of high pressure and temperature hydrothermal oxidation hydrolysis:Macromolecular chain is broken into shorter chainsAccelerate the conversion of sugars and humic acid, improve the quality of organic fertilizerComplete sterilization, the full realization of the sound processing

14、三、不可回收類可燃物焚燒、余熱利用系統經綜合風選機分選出來的高熱值可燃物，如竹木制品、硬質塑料、廢橡膠、破衣物及其它可燃物，具有不可回收、但熱值很高的特點，此類垃圾配入能抑制和吸附氯化物、防止二惡英產生的添加劑和粘接劑，按一定比例混合，進入焚燒爐焚燒。由于添加劑對可燃物燃燒過程中產生的Hce氣體有特殊的吸附作用，所以，有效地抑制了“二惡英”一類有害氣體的產生。焚燒爐產生的熱能供給余熱鍋爐，余熱鍋爐產生的過熱蒸氣供給本廠水解水熱氧化制肥車間，多余熱能或發電或給居民集中供熱或給酒店、賓館、洗浴中心供熱水。該焚燒爐為立式富氧焚燒爐，可燃物進料自上而下，焚燒爐火焰自下而上，可燃物與火焰逆向而行，邊焚燒

15、邊烘干，加之內部出渣爐箅為塔形旋轉結構，所以焚燒徹底，無需加煤或噴油。由于前分選分類比較徹底，很少有塑料焚燒，所以很少產生有害氣體，大大節約了廢氣處理成本，為其它焚燒爐的五分之一。創新環?？萍?提倡綠色焚燒。Non-recyclable fuel burn and residual heat utilize systemFuel of calorific value elected by integrated air separation unit, such as wood products, rigid plastic, rubber, broken clothes and other f

16、uel, are all irrecoverable and high calorific. We add some additives and adhesives, which have quality of inhibition and absorption of chloride, and can prevent the generation of dioxins into the incinerator. For the special absorption of Hce during the burning by additives, effectively inhibit the

17、generation of harmful gases, like “Dioxin”. The heat generated from the incinerator supply heat boiler, which can generate superheated steam supplied to hydrothermal oxidation of fat hydrolysis plant. And excess heat can generate power and central heating supply for residents, hotels, and bath cente

18、r etc.The incinerator is vertical-type oxygen incinerator, fuel feed from the top to the bottom, reserve the line of the blame, burning with the drying, and grate within the slag is the rotating tower structure, so it can completely burn without adding coal or fuel. For the thorough sorting classifi

19、cation of the former, there is little plastic to burn, and generate little harm gas, which significantly saves the cost of waste gas treatment, only one-fifth of other incinerators.Innovative Environmental Technologies, Promote Green incineration四、無機物制造建筑材料系統經綜合風選機分選出來的無機物類垃圾、可燃物類垃圾在焚燒過程中產生的爐渣用于制磚。由

20、于爐渣是通過高溫焚燒形成的產物，一方面自身具有一定的強度，相當于110號的成品水泥，另一方面高溫焚燒徹底，無污染，符合GB508.3-1996危險廢物鑒別標準浸出毒性鑒別。本套系統產生的無機物垃圾、爐渣可以綜合利用，將無機物垃圾、爐渣制成空心磚、道板磚等系列建材產品。既可增加垃圾處理廠的收入，減輕運行費用，又解決了無機物垃圾、爐渣的出路。 主要品種為：增光西班牙道板、機壓西班牙道板、增光草坪磚、機壓六角磚、機壓扭曲磚、機壓彩色路沿石系列、機壓空心磚等。 生產的多孔固化垃圾多孔磚需達到燒結多孔磚（GB13544-2000）的標準的同時，還需滿足Q/JK01-2004固化垃圾多孔磚的標準。Inor

21、ganic Building Materials Manufacture SystemInorganic garbage and slag generated by combustible waste in the incineration process, which is separated by integrated air separation unit can be used to make brick. Since the slag is the product of high temperature incineration, on the one hand it has cer

22、tain strength, the equivalent of 110 finished cement, on the other hand thoroughly incineration with no pollution, which is consistent GB508.3-1996 “Identification standard for hazardous waste leaching toxicity Identification”. Inorganic waste and slag produced by this system can be comprehensive ut

23、ilization, such as making hollow bricks tiles and other building materials. Not only increase revenue of waste treatment plant, but also reduce operating costs, and make full use of inorganic and slag.Main varieties: Spanish plate，machine pressed Spanish plate, lawn brick, hexagonal tile, machine pr

24、essed distorted brick, machine pressed color Curb series, machine pressed hollow bricks.Production of porous brick needs to reach standard of “Fired Brick” (GB13544-2000), meanwhile, to reach standard of Q/JK01-2004 “Curing garbage brick”.五、塑料煉油系統經綜合風選機分選出來的塑料為混合塑料，經人工或機械精選后，可制粒的、附加值比較高的優質塑料去向塑料制粒車間

25、。不可制粒的其它劣質塑料和廢舊輪胎、鞋底類橡膠等去向煉油車間。該設備還可將廢機油、廢柴油、動物脂肪等提煉成燃料油。 技術特色 1、進料連續化   該設備采用一種特殊結構的液體自動密封提升器和氣密推進器將原料順利送入連續反應釜，其關鍵技術在于反應釜內“油氣自動止回器”，絕對保證了反應釜在高溫狀態下能夠連續不斷進料。只準物料進，不讓空氣進。 2、排渣自動化  連續排渣是一項關鍵技術，它是關系到能否真正不間斷生產的核心技術所在。精心設計的固相、液相雙保險自動密封排渣器，確保在高溫條件下隔斷空氣，實現不間斷排渣，從而達到完全意義上的邊進料、邊出油、邊排

26、渣的連續生產。 3、排放環?；?#160;  對于煙氣，采用我司引進的專利產品噴淋、沉降煙氣凈化器專利使黑煙轉變成白煙，排放可達到GB132712001國標。 4、節能充分化   本技術充分利用連續裂解而不斷產生的每小時大約50100公斤的C1C2可燃不凝干氣回收燃燒，基本滿足生產時連續自我加熱的需要，大大降低了生產成本。 煉油設備主要系統 1原料預處理系統；            2連續進料系統；  &#

27、160;         3連續旋轉反應釜； 4、 連續出渣系統；             5換熱系統                  6油水分離系統 7除雜系統  &

28、#160;                 8精制系統                  9過濾系統 10控制系統           &#

29、160;       11環保凈化系統；            12可燃干氣連續凈化回收燃燒系統等Plastic Oil Refining SystemThe plastic elected by integrated air separation unit is mixed plastic, after selection by manual or mechanical, granulation and

30、high value-added quality plastic will be sent to plastic pellet plant. Other low-grade non-pellet plastic, waste tires, and rubber soles etc, will be sent to refining plant. The device can also refine waste oil, waste diesel oil, and animal fat etc into fuel oil.Technical Features1, Continuous feed

31、The device uses a special structure liquid self-sealing device and gas tight propeller smooth the raw material into continuous stirred tank reactor (CSTR), the key technology is the “automatic oil return device” in it, which absolutely guarantee that the reactor at high temperature be continuously f

32、eed, with materials, but no air.2, Slag automation Continuously slag is a key technology, which is related to the ability of uninterrupted production. Solid and liquid double insurance designed self-sealing slag device guarantee that cut off the air in high temperature conditions to achieve continuo

33、us slag. And that is the full sense of the continuous production by feeding, oil discharging, and slag discharging.3, Environmental emissions For gas, we use the patent product induced spray, smoke purifier, which can change black smoke to white smoke, and reach the national standard GB13271-2001.4,

34、 Full energy saving This technology makes full use of dry combustible non-condensable gas generated by continuous cleavage to burn, which can meet the basic needs of self-heating, and can greatly reduce production costsMajor refinery systems1. Raw material pretreatment system; 2. Continuous feed sys

35、tem; 3. Continuous rotator reactor;4. Continuous slag system; 5. Heat exchange system; 6. Oil-water separation system;7. Impurity system; 8. Refinery system; 9. Filtration system;10. Control system; 11. Environmental purification system; 12. Combustion system of continuous purification and recovery

36、of dry combustible gas.六、塑料制粒系統綜合風選機分選出來的混合塑料，經人工或機械精選后，優質塑料進入搓洗池，其余劣質塑料去向塑料煉油系統或者直接回收。 優質塑料進入搓洗池經搓洗機搓洗后，塑料因其比重未發生變化，仍然漂浮在水面，搓洗機轉動帶動水流向前流動時，塑料也隨著往前移動，搓洗池邊放置一塑料撈出機，將撈出的塑料輸送至塑料破碎機進行破碎，破碎后的塑料經3級漂洗、擰干后，進入塑料制粒機制粒；其余垃圾因搓洗破碎后吸濕，其比重發生變化，沉降到水池中部或底部，經泥漿泵連同污水一起去向沉降池，經4級沉降后，清洗水循環使用，沉淀物去向污泥壓濾機，污泥去向水解罐制肥，壓濾水去向一級沉降池。清水補充在第3級漂洗池，與塑料逆向而行，徹底保證了清洗后塑料的清潔。每清洗1噸塑料大約需用水10噸，循環使用后，每清洗1噸塑料需補充清水大約1噸。 燒掉有害,利用是寶.Plastic Granulating SystemThe plastic elected by integrated air separation unit is mixed plastic, after selection by manual or mechanical, high quality plastic will be sent into th