外墻無機保溫系統（mm涂料飾面）砂漿施工方案【專業版】

1、 工程*無機保溫砂漿外墻保溫系統（ mm涂料飾面）施工方案編制單位： *有限公司時 間：2011年 月 日目 錄1.保溫層工程設計要求2.施工準備工作3.施工過程4.施工要點5.施工特殊工藝和部位及注意事項6.質量保證措施7.安全保證措施8.驗收標準*無機保溫系統施工方案1. 保溫層工程設計要求:1.1 基層需滿找平1.2 界面砂漿層(涂刷)+無機保溫層(厚度定為30)+ 抗裂砂漿+耐堿網格布+抗裂砂漿+涂料飾面我公司結合無機保溫砂漿建筑保溫系統應用技術規程 dbj50-103-2010、外墻外保溫工程技術規程及條文說明 jg144-2004，以及建筑外保溫構造圖集，我公司特編制落實以下施工方

2、案：2. 施工準備工作2.1 材料準備所涉及材料：*界面劑（sz601），*無機保溫砂漿砂漿（sz801）、耐堿網格布，*抗裂砂漿（sz321）（如圖）*無機保溫系統基本構造（涂料飾面）基本構造基層混凝土墻及各種砌體墻構造示意圖界面層界面砂漿 保溫層sz無機保溫砂漿抗裂防護層抗裂砂漿耐堿網格布（c型網）飾面層柔性耐水膩?zhàn)?涂料*界面劑（sz601）性能要求：項目計量單位指標壓剪粘結強度原強度mpa0.7耐水mpa0.5耐凍融mpa0.5膨脹玻化微珠性能要求：項目性能指標類類粒徑mm0.51.5堆積密度，kg/m3100120120筒壓強度，kpa150200導熱系數（平均溫度25），w/(mk

3、)0.0480.070體積吸水率，%45體積漂浮率，%80表面玻化閉孔率，%80*無機保溫砂漿（sz801）硬化后性能要求：項目性能指標a型b型c型d型干表觀密度，kg/m330400500600導熱系數，w/(mk)0.0700.0850.100.12抗壓強度（28d），mpa2.5壓剪粘結強度(28d)，kpa80100150200線性收縮率，%0.25軟化系數（28d）0.6燃燒性能級別不燃，a級放射性irira抗凍性（15次凍融循環）質量損失率5%，抗壓強度損失率20%*抗裂砂漿（sz321）性能要求：項目計量單位指標拉伸粘結強度養護28d原強度mpa0.7（養護28

4、d+7d浸水）耐水mpa0.5可操作時間1.5小時，養護28dmpa0.7壓折比/3.0耐堿網格布性能要求：項目性能指標外觀符合jc/t841的規定長度、寬度，m50100、0.91.2網孔尺寸，mm普通型44加強型66單位面積質量，g/普通型160加強型500斷裂強力(經、緯向)，n/50mm普通型1250加強型3000拉伸耐堿斷裂強力保留率(經、緯向)，%90拉伸斷裂伸長率(經、緯向)，%4涂塑量，g/普通型20加強型氧化鋯、氧化鈦含量，%符合jc/t841的規定2.2 工具準備300以上的砂漿攪拌機、攪拌器、泥刀、水平儀、墨斗、鋼卷尺、開槽器、抹刀、滾筒、剪刀、等。2.3 施工設施利用腳

5、手架以及已有的提升設備。2.4 施工作業條件1）、外墻墻體平整度達到要求（水泥砂漿找平），外門窗口安裝完畢，經有關部門檢查驗收合格。2）、門窗邊框與墻體連接應預留出保溫層厚度，縫隙之間分層填塞嚴密，做好門窗表面防護。3）、外墻外表面的雨水管卡、預埋鐵件、設備穿墻管道等提前安裝完畢，并預留出保溫層的厚度。4）、施工用吊藍或腳手架搭設牢固，安全檢驗合格。5）、預制混凝土外墻板縫處應提前處理好。2.5 施工要求氣候條件環境溫度不得低于5，風力不應大于5級，風速不得大于10m/s。雨季施工時應做好防雨措施。3. 施工過程3.1 基面處理（結構基層處理） 除去所有基面松動空殼部分，填補所有裂縫、凹洞等。

6、基面必須平整清潔，使用水平靠尺以確保平整（每2米內至多5mm的起伏）對于局部平整度較差的基面，應銼去過高的突出物，平整基面，局部使用水泥砂漿找平3.2 外墻飾面為涂料面層的無機保溫施工技術方案及工藝流程：成品保護外墻面基層清理 抹1：2.5水泥砂漿找平層 打耙涂刷界面劑 抹無機砂漿保溫層（15mm時，可以一遍成活；15mm，至少兩遍成活） 抹抗裂砂漿層（抹第一遍抗裂時，同時鋪壓玻纖網，再抹第二遍抗裂）外墻飾面3.3保溫施工工藝流程圖：（涂料飾面）基層墻體處理門窗洞口堵縫、穿墻套管、卡處理吊垂直、套方、彈控制線涂刮界面砂漿用保溫漿料作灰餅、沖筋作口抹第一遍保溫漿料，厚度15抹第二遍保溫漿料, 壓

7、實刮平彈分格線、分格槽涂料飾面施工抹抗裂砂漿、壓耐堿網格布、壓實刮平檢驗平整度驗收4. 施工要點：4.1 材料配制無機保溫砂漿以及相應的保溫砂漿材料現場配制必須嚴格執行相關的配制工藝（必須按照我公司技術人員提供的比例進行配置），做到專人定崗、集中攪拌。4.2 基層墻面處理墻面應清理干凈無油漬、浮塵等，舊墻面松動、風化部分應剔鑿干凈。墻表面凸起物10mm應鏟平。4.3 保溫層施工吊垂直、套方、彈控制線、水平通線，套方作口，用無機保溫漿料作標準厚度灰餅沖筋。4.4 涂刷界面劑在墻體表面涂刷界面劑，4.5 無機保溫漿料的施工a.抹無機保溫漿料應每遍施工不應超過15mm，每?jī)杀殚g隔應在24h以上。b.

8、后一遍施工厚度要比前一遍施工厚度小。最后一遍厚度控制在10mm左右為宜。c.最后一遍操作時應達到?jīng)_筋厚度并用大杠搓平，墻面門窗口平整度達到要求。d.保溫層固化干燥后，方可進行抗裂保護層施工。4.6 抹抗裂砂漿，鋪貼網網格布按墻體尺寸事先裁好。抹抗裂砂漿第一遍時同時鋪壓網格布，要求壓實、平整，隨后抹第二遍抗裂砂漿，以僅覆蓋網格布為宜。抗裂層總厚度3-mm。4.7 平整度檢查抹完抗裂砂漿后，應檢查平整、垂直及陰陽角方正，對于不符合要求的進行修補，使完成面達到垂直平整。5. 施工特殊工藝和部位及注意事項5.1 *無機保溫系統抹灰施工中如何吊垂直、套方、彈控制線1）、在頂部墻面固定膨脹螺栓，作為掛先的

9、垂掛點；2）、根據室內三線向室外返出外保溫抹灰厚度控制點，然后固定垂直控制線兩端；3）、復測每層三線到垂直控制通線的距離是否一致，偏差超過20mm找出原因做出相應處理。4）、根據垂直控制通線作垂直方向的灰餅，在根據兩垂直方向灰餅之間的通線，作墻面保溫層厚度控制灰餅，灰餅之間的距離不得超出2m。5.2 *界面劑（sz601）的使用要求現澆混凝土外墻外表面及即有建筑物外墻外表面必須涂刷界面劑。5.3 *無機保溫砂漿施工的一般做法1）、抹無機保溫漿料應至少分兩次施工,當厚度不超過15mm時，可一遍成活，超過15mm時，至少兩遍成活。2）、后一遍施工厚度要比前一遍厚度薄，最后一遍厚度控制在10mm左右

10、為宜。3）、最后一遍操作時應達到?jīng)_筋厚度并用大杠刮平，墻面門窗口平整度應達到驗收標準。4）、保溫層充分固化后方可進行下一步施工。5.4 *無機保溫抹灰體系施工時注意事項1）、管道、槽盒上殘存砂漿，應及時清理干凈。2）、翻拆架子應防止破壞以抹好的墻面，其它工種作業時不得污染或損壞墻面，嚴禁踩踏窗口。3）、各構造層在凝結前應防止水沖、撞擊、振動。4）、應遵守有關安全操作規程。新工人必須經過技術培訓和安全教育方可上崗。腳手架經安全檢查驗收合格后，方可上人施工，施工時應有防止工具、用具、材料墜落的措施。5.5 特殊部位的處理：1）陰陽角的翻包處理：?jiǎn)螌泳W(wǎng)格布系統應在陰陽角處設加強網，延兩側墻面大于20

11、。加強網格布的接縫為對接，接縫應對齊平整；其翻包包邊寬度不小于1o；6 質量保證措施6.1 質量目標：創建優質工程質量方針：遵循建筑業法律法規,視產品質量為企業的生命,對施工全過程實施質量控制,持續改進質量管理體系,為顧客提供滿意的產品和服務,努力把每一項工程建立成同行業一流產品.6.2 基礎工作按設立專職質檢員和成品保護管理員崗位，建立崗位責任制。6.3 物資檢驗規定對所有進場的材料組織檢查驗收，建立臺帳。所有進場物資必須隨材料進場提供合格的材質證明、出廠合格證和試驗報告。對進場的物資必須進行標識，按照已經經過檢驗、未經檢驗和經檢驗不合格等三種狀態進行分各類堆放，嚴格保管，避免用不合格的材料

12、。對不合格物資，堅決要求不準進場，同時要注明處理結果和材料去向。對不合格材料的處理，應建立臺帳。7. 安全保證措施7.1 操作人員上下架子，要有保證人員安全的吊籠、扶梯、爬梯或斜道。7.2 吊、掛腳手架使用的挑梁、梁、吊架、鋼絲繩和其他繩索，使用前要作荷載檢驗，均必須滿足規定安全系數，升降設備必須有可靠的制動裝置。7.3 必須有良好的防電、避雷裝置，鋼腳手架等均應可靠接地，高于四周建筑物的腳手架應架設避雷裝置。7.4 必須按規定設剪刀撐和支撐，高于7m的架子必須和建筑物連接牢固，保證架子不搖晃。腳手架上要滿鋪跳板，不得鋪單塊跳板且不得留探頭板，跳板保證有三個支撐點，并綁扎牢固。7.5 在腳手架

13、搭設和使用過程中，必須隨時進行檢查，經常清除架上的垃圾，注意控制架上荷載，禁止在架上過多堆放材料和多人擠在一起。7.6 遇有6級以上大風或大霧、大雨，應暫停高處作業，雨、雪后上架操作要有防滑措施。7.7 高空作業掛好安全帶，進入施工現場戴好安全帽，嚴格遵守各工種操作規程施工。8. 驗收標準無機保溫砂漿建筑保溫系統應用技術規程 dbj50-103-2010外墻外保溫工程技術規程及條文說明 jg144-2004居住建筑節能工程施工質量驗收規程 dbj50-045-2005重慶市居住建筑節能設計標準 db50/5024-2002建筑節能工程施工質量驗收規范 gb50411-2007g an empl

14、oyment tribunal claimemployment tribunals sort out disagreements between employers and employees.you may need to make a claim to an employment tribunal if: you dont agree with the disciplinary action your employer has taken against you your employer dismisses you and you think that you have been dis

15、missed unfairly.for more information about dismissal and unfair dismissal, seedismissal.you can make a claim to an employment tribunal, even if you haventappealedagainst the disciplinary action your employer has taken against you. however, if you win your case, the tribunal may reduce any compensati

16、on awarded to you as a result of your failure to appeal.remember that in most cases you must make an application to an employment tribunal within three months of the date when the event you are complaining about happened. if your application is received after this time limit, the tribunal will not u

17、sually accept it.if you are worried about how the time limits apply to you, take advice from one of the organisations listed underfurther help.employment tribunals are less formal than some other courts, but it is still a legal process and you will need to give evidence under an oath or affirmation.

18、most people find making a claim to an employment tribunal challenging. if you are thinking about making a claim to an employment tribunal, you should get help straight away from one of the organisations listed underfurther help.if you are being represented by a solicitor at the tribunal, they may as

19、k you to sign an agreement where you pay their fee out of your compensation if you win the case. this is known as adamages-based agreement. in england and wales, your solicitor cant charge you more than 35% of your compensation if you win the case.if you are thinking about signing up for a damages-b

20、ased agreement, you should make sure youre clear about the terms of the agreement. it might be best to get advice from an experienced adviser, for example, at a citizens advice bureau. to find your nearest cab, including those that give advice by e-mail, click onnearest cab.for more information abou

21、t making a claim to an employment tribunal, seeemployment tribunals.the (lack of) air up there watch mcayman islands-based webb, the head of fifas anti-racism taskforce, is in london for the football associations 150th anniversary celebrations and will attend citys premier league match at chelsea on

22、 sunday.i am going to be at the match tomorrow and i have asked to meet yaya toure, he told bbc sport.for me its about how he felt and i would like to speak to him first to find out what his experience was.uefa hasopened disciplinary proceedings against cskafor the racist behaviour of their fans dur

23、ingcitys 2-1 win.michel platini, president of european footballs governing body, has also ordered an immediate investigation into the referees actions.cska said they were surprised and disappointed by toures complaint. in a statement the russian side added: we found no racist insults from fans of cs

24、ka.age has reached the end of the beginning of a word. may be guilty in his seems to passing a lot of different life became the appearance of the same day; may be back in the past, to oneself the paranoid weird belief disillusionment, these days, my mind has been very messy, in my mind constantly. a

25、lways feel oneself should go to do something, or write something. twenty years of life trajectory deeply shallow, suddenly feel something, do it.一字開頭的年齡已經到了尾聲?；蛟S是愧疚于自己似乎把轉瞬即逝的很多個不同的日子過成了同一天的樣子；或許是追溯過去，對自己那些近乎偏執的怪異信念的醒悟，這些天以來，思緒一直很凌亂，在腦海中不斷糾纏。總覺得自己自己似乎應該去做點什么，或者寫點什么。二十年的人生軌跡深深淺淺，突然就感覺到有些事情，非做不可了。the

26、end of our life, and can meet many things really do?而窮盡我們的一生，又能遇到多少事情是真正地非做不可？during my childhood, think lucky money and new clothes are necessary for new year, but as the advance of the age, will be more and more found that those things are optional; junior high school, thought to have a crush on j

27、ust means that the real growth, but over the past three years later, his writing of alumni in peace, suddenly found that isnt really grow up, it seems is not so important; then in high school, think dont want to give vent to out your inner voice can be in the high school children of the feelings in

28、a period, but was eventually infarction when graduation party in the throat, later again stood on the pitch he has sweat profusely, looked at his thrown a basketball hoops, suddenly found himself has already cant remember his appearance.童年時，覺得壓歲錢和新衣服是過年必備，但是隨著年齡的推進，會越來越發現，那些東西根本就可有可無；初中時，以為要有一場暗戀才意味

29、著真正的成長，但三年過去后，自己心平氣和的寫同學錄的時候，突然就發現是不是真正的成長了，好像并沒有那么重要了；然后到了高中，覺得非要吐露出自己的心聲才能為高中生涯里的懵懂情愫劃上一個句點，但畢業晚會的時候最終還是被梗塞在了咽喉，后來再次站在他曾經揮汗如雨的球場，看著他投過籃球的球框時，突然間發現自己已經想不起他的容顏。originally, this world, can produce a chemical reaction to an event, in addition to resolutely, have to do, and time.原來，這個世界上，對某個事件能產生化學反應的，

30、除了非做不可的堅決，還有，時間。a persons time, your ideas are always special to clear. want, want, line is clear, as if nothing could shake his. also once seemed to be determined to do something, but more often is he backed out at last. dislike his cowardice, finally found that there are a lot of love, there are a

31、 lot of miss, like shadow really have been doomed. those who do, just green years oneself give oneself an arm injection, or is a self-righteous spiritual.一個人的時候，自己的想法總是特別地清晰。想要的，不想要的，界限明確，好像沒有什么可以撼動自己。也曾經好像已經下定了決心去做某件事，但更多的時候是最后又打起了退堂鼓。嫌惡過自己的怯懦，最終卻發現有很多緣分，有很多錯過，好像冥冥之中真的已經注定。那些曾經所謂的非做不可，只是青蔥年華里自己給自己注

32、射的一支強心劑，或者說，是自以為是的精神寄托罷了。at the moment, the sky is dark, the air is fresh factor after just rained. suddenly thought of blue plaid shirt; those were broken into various shapes of stationery; from the corner at the beginning of deep friendship; have declared the end of the encounter that havent start

33、 planning. those years, those days of do, finally, like youth, will end in our life.此刻，天空是陰暗的，空氣里有著剛下過雨之后的清新因子。突然想到那件藍格子襯衫；那些被折成各種各樣形狀的信紙；那段從街角深巷伊始的友誼；還有那場還沒有開始就宣告了終結的邂逅計劃那些年那些天的非做不可，終于和青春一樣，都將在我們的人生中謝幕。baumgartner the disappointing news: mission aborted. r plays an important role in this mission. s

34、tarting at the ground, conditions have to be very calm - winds less than 2 mph, with no precipitation or humidity and limited cloud cover. the balloon, with capsule attached, will move through the lower level of the atmosphere (the troposphere) where our day-to-day weather lives. it will climb highe

35、r than the tip of mount everest (5.5 miles/8.85 kilometers), drifting even higher than the cruising altitude of commercial airliners (5.6 miles/9.17 kilometers) and into the stratosphere. as he crosses the boundary layer (called the tropopause),e can expect a lot of turbulence.the supersonic descent could happen as early as sunda.the weathethe balloon will slowly drift to the edge of space at 120,000 feet ( then, i would assume, he will slowly step out onto something resembling an olympic diving platform.below, the earth becomes the concrete bottom of a swimming pool