《煙用絲束》行業標準修訂項目技術報告

《煙用絲束》行業標準修訂項目技術報告2主要研究內容一級分類二級分類單絲線密度的范圍（dtex）常規絲束低單旦絲束標稱值≤2.22中單旦絲束2.22＜標稱值＜5.00特規絲束中高單旦絲束5.00≤標稱值＜6.67高單旦絲束6.67≤標稱值＜16.67超高單旦絲束標稱值≥16.67目前絲束線密度從1.67ktex延伸到7.78ktex，單絲線密度從1.78dtex延伸到24.4dtex鑒于打掃碼系統二維碼編碼中第31和32位為小類分類碼（01原分類方式源自特規絲束定義“絲束線密度大于或等于4.44ktex24.4dtex，其設計主要呈現了三個系等規格由原來的特規絲束調整為常規絲束；5.00Y3.33、5.33Y2.44、各家信息化系統實施存在先后，建議過渡期設為24個月。能性絲束的開發需求，相關添加劑種類可能超出現有名單。本標準規定了所有規格絲束符合性要求（見表2特規絲束不項目類別單絲線密度低單旦絲束、中單旦絲束、中高單旦絲束、高單旦絲束超高單旦絲束絲束線密度≤2.22ktex>2.22ktex各類別絲束的單絲線密度呈現以下特點（見表3）：（1）超高單旦絲束代表規格的測定值/標稱值的比值、控制限/段絲束的單絲線密度數值較高，同等倍數下，其標稱允許范圍較寬。（2）高單旦絲束的單絲線密度測定值/標稱值的比值、控制限/但測定值未超出。建議加強生產過程控制，減小質量波動。（4）中單旦絲束的單絲線密度測定值/標稱值的比值普遍為密度測定值/標稱值的比值最低為0.89,4.22Y3.78和4.33Y3.44的控制下限/標稱值的比值為0.88，超出標稱下限。建議加強絲束生產過程中單旦絲束和中高單旦絲束的單絲線密度數據滿足原標準標稱高單旦絲束的單絲線密度要求較為合理。類別規格廠家測定均值測定最大值測定最小值測定上限/標稱值測定下限/標稱值標準偏差控制上限控制下限控制上限/標稱值控制下限/標稱值超高單旦22.2Y3.00(20Y27000)123.3524.7222.320.7825.6921.010.95高單旦絲束13.3Y1.67(12Y15000)六家0.960.310.928.89Y1.67(8.0Y15000)19.519.609.380.109.819.2129.049.188.859.468.620.9738.548.558.520.960.960.028.608.480.970.9528.378.707.880.980.890.198.947.800.8869.589.679.490.049.709.468.33Y1.78(7.5Y16000)18.668.818.540.108.968.3628.889.228.200.980.387.740.9348.358.488.260.990.108.658.060.9759.329.639.019.658.9869.659.799.560.099.929.386.67Y1.89(6.0Y17000)17.517.677.400.087.757.2727.477.527.390.037.567.3847.447.737.237.7757.307.447.666.9467.407.517.247.737.076.44Y2.89(5.8Y26000)16.916.986.790.076.7026.957.056.880.037.046.8647.277.417.040.097.547.0056.867.226.597.286.445.33Y2.4415.785.915.680.086.025.54(4.8Y22000)5.00Y3.33(4.5Y30000)35.085.040.025.02中單旦絲束4.33Y3.44(3.9Y31000)14.424.544.310.074.634.210.9724.504.594.400.084.744.260.9824.674.764.570.044.794.5544.013.880.950.900.064.203.820.970.8854.424.594.300.990.074.634.210.974.22Y3.78(3.8Y34000)14.504.574.450.054.654.3524.304.354.230.044.424.180.9934.294.324.220.034.384.2044.004.203.770.890.104.293.710.8854.094.273.960.940.084.333.850.9164.224.444.030.950.074.434.010.953.33Y3.56(3.0Y32000)13.423.503.340.053.573.270.9823.623.683.570.043.743.5023.343.453.270.980.043.463.220.9733.343.383.310.990.023.403.280.9843.253.453.010.900.073.453.050.9253.443.653.250.980.083.683.200.9663.513.653.330.063.693.333.00Y3.89(2.7Y35000)13.163.050.053.262.960.9923.103.133.070.023.163.0453.063.212.930.980.053.212.910.972.44Y3.78(2.2Y34000)12.652.722.570.042.772.53低單旦絲束1.78Y2.89(1.6Y26000)1/////針對該段絲束，根據表4數據分析，其測定值/標稱值的比值符規格廠家測定均值測定最大值測定最小值測定最大值/標稱值測定最小值/標稱值5.33Y2.44(4.8Y22000)12.452.462.4322.442.462.4332.452.472.4342.452.472.420.996.44Y2.89(5.8Y26000)12.872.892.860.9922.812.832.790.980.9732.892.942.840.9842.912.922.8952.923.002.885.00Y3.33(4.5Y30000)33.313.333.280.985.56Y3.33(5.0Y30000)53.383.483.310.994.33Y3.44(3.9Y31000)13.443.453.4423.523.553.5043.533.563.4653.503.543.433.33Y3.56(3.0Y32000)13.563.583.5523.553.573.530.9933.543.663.500.9843.553.643.380.953.563.593.530.993.503.533.440.990.9763.553.673.500.982.44Y3.7813.793.823.760.99(2.2Y34000)4.22Y3.78(3.8Y34000)33.763.863.690.9843.743.803.700.98備注：絲束生產廠家用數字隨機表示（下同）。規格參數測定均值測定最大值測定最小值測定最大值/標稱值測定最小值/標稱值6.67Y4.44(6.0Y40000)/4.444.504.390.996.67Y6.00(6.0Y54000)原（22N）6.186.236.15新（33N）6.076.036.67Y7.78(6.0Y70000)原（22N）8.188.208.13新（44N）7.867.917.80綜上所述，絲束線密度大于2.22ktex的絲束，其絲束線密度與該段絲束的絲束線密度測定值在“0.95~1.05倍”的基礎上同步向規格廠家測定均值（ktex）測定最大值測定最小值測定最大值/標稱值測定最小值/標稱值8.89Y1.67(8.0Y15000)120.9345///613.3Y1.67(12Y15000)10.99468.33Y1.78(7.5Y16000)10.99230.94450.996(9.1Y16000)46///6.67Y1.89(6.0Y17000)10.9820.9940.9950.9760.997.44Y1.89(6.7Y17000)12.002.02標準偏差來計算控制限、控制限/標稱值。該段絲束控制限/標稱值的規格廠家測定均值標準偏差控制上限控制下限控制上限/標稱值控制下限/標稱值8.89Y1.67(8.0Y15000)10.0120.040.8840.015/////60.0113.3Y1.67(12Y15000)10.010.9840.0160.018.33Y1.78(7.5Y16000)10.0120.0130.0140.0150.0160.01(9.1Y16000)40.016/////6.67Y1.89(6.0Y17000)10.010.9820.010.9840.010.9950.010.9860.010.997.44Y1.89(6.7Y17000)12.000.012.03備注：1.控制上限：測定均值+3*標準偏差2.控制下限：測定均值-3*標準偏差大于2.22ktex的絲束，其絲束線密度的設計范圍普遍處于標稱值的0.88~1.07倍內，且設計偏移較絲束線密度大于2.22ktex的絲束向下針對未來可能開發的其他非Y型絲束，字母代碼由生產企業自單絲橫截面形狀字母代碼Y型絲束Y非Y型絲束XIR其他由生產企業自定義歐盟委員會發布2020/217號條例，將二氧化鈦在粉末形式下，歐盟法院基于對科學證據的嚴謹性，廢除了該條例，二氧化鈦被“解GB2760-2024《食品安全國家標準食品添加劑使用標準》于上煙集團牽頭的行業標準預研項目“含二氧化鈦卷煙原輔材料的質量安全研究”，基于風險最大化原則設計了卷煙原輔材料中二氧化2021年，三纖公司技術中心牽頭開展三纖公司二氧化鈦聯調，要求。該類絲束除滿足技術指標等基本要求外，基于卷煙設計“新奇特”的需要，用戶還會提出個性化要